 Open Access Article
 Open Access Article
Aoni Xu ab, 
Chaofang Dong*a, 
Xin Weia, 
Xiaogang Lia and 
Digby D. Macdonaldb
ab, 
Chaofang Dong*a, 
Xin Weia, 
Xiaogang Lia and 
Digby D. Macdonaldb
aCorrosion and Protection Center, Key Laboratory for Corrosion and Protection (MOE), University of Science and Technology Beijing, Beijing 100083, China. E-mail: cfdong@ustb.edu.cn;  Fax: +86-10-62334005;   Tel: +86-10-62333931 extn 518
bDepartment of Material Science and Engineering, The University of California at Berkeley, Berkeley, CA 94720, USA
First published on 21st May 2019
The destructive role of chloride ions on the defect structure of barrier layers (bl) is vitally important for understanding the initial breakdown of passive films on metals. Here photo-electrochemical and density functional theory (DFT) were applied to investigate the influence of chloride on the defect structure of the bl in passive films. The results show a bl with a narrow band gap, in which the valence band maximum (VBM) increased upon introducing chloride into the electrolyte. DFT calculations indicate that an increase in the copper vacancy concentration, due to cation extraction at the bl/solution interface could increase the VBM while oxygen vacancy generation results in a decrease in the conduction band minimum (CBM). The combination of these results verifies the aggressive role of chloride as proposed by the Point Defect Model (PDM) where an enhancement of the cation vacancy concentration across the bl occurs in response to the absorption of Cl− into oxygen vacancies on the bl.
 8 However, the role of highly defective structure of the passive film should not be neglected when we discuss the detailed mechanism of chloride ion-induced breakdown. Our previous work9 has demonstrated that the breakdown of passive films on copper in chloride solution is due to the adsorption behavior rather than the penetration of Cl− into the barrier oxide layer (bl) by both experiment and Density Functional Theory (DFT) calculations. A further investigation should be performed aimed at the detailed process of initial breakdown of the passive film induced by adsorbed chloride ions in solution. It is evident that the point defect structure of the bl is vitally important in understanding the physico-electrochemistry of passivity breakdown on metals and alloys.10 Thus, how the chloride ions impact the defect structure of passive film would be crucial to understand the initial breakdown. Not surprisingly, this has led many workers to examine the defect structure of bls using a variety of techniques.11–13 However, the defect structure of a barrier layer is difficult to define directly using conventional methods, such as photoluminescence excitation14 and positron annihilation spectroscopy (PAS),15 since the bl of a passive film is generally so thin (1–10 nm) that it is impossible to separate its response from that of the metal substrate. In past studies, researchers usually measured the carrier concentration in passive film using Mott–Schottky analysis (MSA) and used the results to reflect upon the variation of the point defect concentration.16–19 Nevertheless, the value of point defect concentration in the bl, as determined by MSA, is problematic, as noted elsewhere,20 and the relationship between point defect and carrier (electron and hole) concentrations is not well-defined because a lack of confluence between Mott–Schottky theory and the bl, which is not a simple p–n junction. Fortunately, the variation of the band structure also could reflect the change in the point defect concentration, since the point defects act as the dopants. Taking cuprous oxide (Cu2O) as an example, Paul et al.21 pointed out that the presence of copper vacancy could introduce hole states located on about 0.45 eV above the valence band maximum (VBM) in the band structure.
8 However, the role of highly defective structure of the passive film should not be neglected when we discuss the detailed mechanism of chloride ion-induced breakdown. Our previous work9 has demonstrated that the breakdown of passive films on copper in chloride solution is due to the adsorption behavior rather than the penetration of Cl− into the barrier oxide layer (bl) by both experiment and Density Functional Theory (DFT) calculations. A further investigation should be performed aimed at the detailed process of initial breakdown of the passive film induced by adsorbed chloride ions in solution. It is evident that the point defect structure of the bl is vitally important in understanding the physico-electrochemistry of passivity breakdown on metals and alloys.10 Thus, how the chloride ions impact the defect structure of passive film would be crucial to understand the initial breakdown. Not surprisingly, this has led many workers to examine the defect structure of bls using a variety of techniques.11–13 However, the defect structure of a barrier layer is difficult to define directly using conventional methods, such as photoluminescence excitation14 and positron annihilation spectroscopy (PAS),15 since the bl of a passive film is generally so thin (1–10 nm) that it is impossible to separate its response from that of the metal substrate. In past studies, researchers usually measured the carrier concentration in passive film using Mott–Schottky analysis (MSA) and used the results to reflect upon the variation of the point defect concentration.16–19 Nevertheless, the value of point defect concentration in the bl, as determined by MSA, is problematic, as noted elsewhere,20 and the relationship between point defect and carrier (electron and hole) concentrations is not well-defined because a lack of confluence between Mott–Schottky theory and the bl, which is not a simple p–n junction. Fortunately, the variation of the band structure also could reflect the change in the point defect concentration, since the point defects act as the dopants. Taking cuprous oxide (Cu2O) as an example, Paul et al.21 pointed out that the presence of copper vacancy could introduce hole states located on about 0.45 eV above the valence band maximum (VBM) in the band structure.
Furthermore, exploring the relationship between point defects and electronic structure of material by first principle calculations to explain reaction mechanism or guide material design has been generally accepted and has made significant progress in recent years. Raebiger et al.22 studied the formation enthalpies of copper vacancy (VCu) and oxygen interstice (Oi) using DFT and found that the cation deficiency of Cu2O is accommodated mostly by Cu vacancies VCu rather than by oxygen interstitials Oi (that is, the stoichiometry of the bl is Cu2−xO rather than Cu2O1+y, both of which give Cu/O < 2). Thus, in this paper, we used photo-electrochemical spectra to measure the band gap and ultraviolet photoelectron spectroscopy (UPS) to assess the position of VBM relative to the Fermi level. In this way, a simplified band structure of passive film could be obtained. Furthermore, defective Cu2O slab models were employed to simulate the barrier layer on copper. The characteristic band structures were identified for various kinds of point defects using HSE functional. Finally, a rational, theoretical explanation combined with experimental observation, was proposed to explain the effect of chloride on the defect structure of bl and hence for the occurrence of initial passivity breakdown.
Potentiodynamic polarizations (PDP) were commenced in the negative-to-positive direction at a scan rate of 0.1667 mV s−1 after pre-performed cathodically polarization at −0.6 V vs. SCE. Subsequently, anodic polarization at 0.2 V in passivity range was performed for 24 h to generate a steady-state passive film. Then, the work functions of passive films were measured using a Thermo Scientific ESCALab 250Xi system employing UPS. The gas discharge lamp was used with admitted helium gas and the HeI (21.22 eV) emission line employed. In the meantime, we performed photo-electrochemical measurements using a 150 W xenon lamp and a 1200/mm grating monochromator just after anodic polarization. The photocurrent spectra were obtained by scanning the light wavelength in steps of 10 nm from 800 to 300 nm. All of the electrochemical and photo-electrochemical experiments were achieved on a Solartron Analytical Modulab photo-electrochemistry workstation.
| α = A(hν − Eg)n/hν | (1) | 
| Experimental results | Calculation results | ||
|---|---|---|---|
| Electrolyte | Work function/eV | Orientation | Surface energy/eV Å−2 | 
| 0.0 M NaCl | 4.86 | Cu2O (100) | 0.10 | 
| 0.1 M NaCl | 4.70 | Cu2O (110) | 0.08 | 
| 0.5 M NaCl | 4.48 | Cu2O (111) | 0.04 | 
Taking the results of band gap, position of the VBM, and work function into consideration, the band structures of the bl can be represented as Fig. 1(d). The bl of the passive film grown in 0.5 M NaCl had the narrowest band gap and the highest Fermi level (lowest work function), while the band gaps and Fermi levels were similar for the bls formed in two other solutions. Combining with the introducing of doping states by point defect, this change in band structure of passive film demonstrated that the chloride ions in electrolyte play a significant role in determining the defect structure of the bl by creating fresh vacancies. A similar increasing tendency of carrier density was also reported by Fattah-Alhosseini33 by Mott–Schottky analysis. However, the interaction between chloride ions and the bl still lacks detail. Oxygen vacancies  and cation vacancies
 and cation vacancies  in the bl, and even chloride absorbed into surface oxygen vacancies
 in the bl, and even chloride absorbed into surface oxygen vacancies  in bl, can all generate electronic doping states in the band gap, which renders the process difficult to be analyzed only from experiment. Thus, a more detailed analysis is warranted by using first-principles calculations.
 in bl, can all generate electronic doping states in the band gap, which renders the process difficult to be analyzed only from experiment. Thus, a more detailed analysis is warranted by using first-principles calculations.
On the most stable O-terminated Cu2O (111) surface, 4 kinds of ions exist, named as Cu-1, Cu-2, O-3 and O-4 according to their coordination numbers [Fig. 2(g)]. We first investigated the surface work functions for complete and defective surface. For a perfect Cu2O (111) surface, the work function equals to 4.87 eV which is very similar with our experimental result in Table 1. However, when we introduce surface point defect on our slab model, the work function values all decreased obviously where 4.77 and 4.75 eV for  and
 and  , 4.73 and 4.70 eV for
, 4.73 and 4.70 eV for  and
 and  , respectively. We also calculated the work function for the adsorption model of chloride, where 5.04 and 5.35 eV for the configurations of Cl absorbed on Cu-1 and Cu-2. Therefore, a reasonable explanation for the decreasing work functions with increase in molarity of Cl observed in experiments was proposed “The barrier layer formed in a dense Cl-containing solution has a more defective structure”. Furthermore, Fig. 2 displays the band structures and DOS of Cu2O (111) with a copper or oxygen vacancies or an oxygen vacancy occupied by chloride. We have discussed the effect of cation vacancies on electronic properties and magnetic moments in detail in our previous work,24 where O 2p and Cu 3d states dominate an additional acceptor state above VBM in band gap. On the contrary, for oxygen vacancies, especially Cl-occupied oxygen vacancies, a clear shift down of CBM was observed by introducing a donor state in the band gap [Fig. 2e and f]. Similarly, 3d states of copper atoms surrounding oxygen vacancy dominate the extension of the conduction band owing to the unsaturated dangling bonds appearing around the vacancy. The donor state introduced by Cl-occupied oxygen vacancy never changes the direct gap feature of stoichiometric Cu2O compared with an unoccupied oxygen vacancy, which shifts the direct transition point in the Brillouin zone from Point γ- to Point B point for
, respectively. We also calculated the work function for the adsorption model of chloride, where 5.04 and 5.35 eV for the configurations of Cl absorbed on Cu-1 and Cu-2. Therefore, a reasonable explanation for the decreasing work functions with increase in molarity of Cl observed in experiments was proposed “The barrier layer formed in a dense Cl-containing solution has a more defective structure”. Furthermore, Fig. 2 displays the band structures and DOS of Cu2O (111) with a copper or oxygen vacancies or an oxygen vacancy occupied by chloride. We have discussed the effect of cation vacancies on electronic properties and magnetic moments in detail in our previous work,24 where O 2p and Cu 3d states dominate an additional acceptor state above VBM in band gap. On the contrary, for oxygen vacancies, especially Cl-occupied oxygen vacancies, a clear shift down of CBM was observed by introducing a donor state in the band gap [Fig. 2e and f]. Similarly, 3d states of copper atoms surrounding oxygen vacancy dominate the extension of the conduction band owing to the unsaturated dangling bonds appearing around the vacancy. The donor state introduced by Cl-occupied oxygen vacancy never changes the direct gap feature of stoichiometric Cu2O compared with an unoccupied oxygen vacancy, which shifts the direct transition point in the Brillouin zone from Point γ- to Point B point for  and introduces an indirect gap for
 and introduces an indirect gap for  .
.
|  | ||
| Fig. 2  Band structures and DOS of Cu2O (111) with (a)  ; (b)  ; (c)  ; (d)  ; (e)  ; (f)  ; (g) side view of Cu2O (111) slab model. | ||
It should be noted that the real bl is inhomogeneous with gradients of the electric field and of the distribution of vacancies. Naturally, the field penetration and band bending must exist across the bls on metals owing the variational phase environment. However, it's almost impossible to create a model with the same distribution of vacancies and also electric field as a real passive film which is still a mystery on characterization experiments. Similarly, we have to be honest to say we cannot calculate the exact band structure of bl. But, we can apply the calculated electronic structure of cuprous oxide in a specific defective structure to analyze the effective role of a specific defect on electronic properties for bl by comparing calculation results of defective model and complete one. That's because the effective role of a specific vacancy for a semiconductor whether perfect or defective remains unchanged. Taking copper vacancy as an example, copper vacancy always acts as acceptor introducing hole states over valence band in band structure for CuxO (1 < x < 2).22,35,36 To demonstrate that in detail, we also supplemented many electronic structure calculations under electric field of various values and with different defect concentrations.
Fig. 3 shows the band structures of Cu2O (111) slab model with one  under 0, 1, 3 and 5 × 106 V cm−1 electric field. Meanwhile, the direction of applied electric field is parallel to z axis and the vacuum layer. As seen, the copper vacancy VCu-1 always acts as acceptor and introduce a shallow hole state above valence band no matter in which electric field. The electronic structures of cuprous oxide with different defect concentration were calculated to indicate the effective role of a specific defect on band structure for oxide is not going to change due to varying concentration. The results were shown in Fig. 4. We improved the vacancy concentration by removing more cations or oxygen ions from Cu2O (111) model. All of the band structures were obtained after relaxation calculations. From Fig. 4, it's clearly that the copper vacancy always can increase valence band maximum by introducing acceptor states in band gap no matter with any concentration of itself or oxygen vacancies. Similarly, the oxygen vacancy always cannot increase valence band maximum in any conditions. Thus, transplanting these results to passive film, only copper vacancy in bl could increase the VBM, while oxygen vacancy and chloride-occupied oxygen vacancy just result in a decrease in CBM.
 under 0, 1, 3 and 5 × 106 V cm−1 electric field. Meanwhile, the direction of applied electric field is parallel to z axis and the vacuum layer. As seen, the copper vacancy VCu-1 always acts as acceptor and introduce a shallow hole state above valence band no matter in which electric field. The electronic structures of cuprous oxide with different defect concentration were calculated to indicate the effective role of a specific defect on band structure for oxide is not going to change due to varying concentration. The results were shown in Fig. 4. We improved the vacancy concentration by removing more cations or oxygen ions from Cu2O (111) model. All of the band structures were obtained after relaxation calculations. From Fig. 4, it's clearly that the copper vacancy always can increase valence band maximum by introducing acceptor states in band gap no matter with any concentration of itself or oxygen vacancies. Similarly, the oxygen vacancy always cannot increase valence band maximum in any conditions. Thus, transplanting these results to passive film, only copper vacancy in bl could increase the VBM, while oxygen vacancy and chloride-occupied oxygen vacancy just result in a decrease in CBM.
|  | ||
| Fig. 3 Band structures of Cu2O (111) with one VCu-1 under (a) 0, (b) 1, (c) 3 and (d) 5 × 106 V cm−1 electric field. | ||
|  | ||
| Fig. 4 Band structures of Cu2O (111) with different concentrations of copper vacancies or oxygen vacancies. | ||
Combining with experimental results where VBM increased significantly with introducing chloride into the electrolyte, a reasonable speculation could be concluded that an increase of copper vacancy concentration in passive film would be substantial indeed owing to the participation of chloride ions. This conclusion is coincidentally in agreement with the assumption of Point Defect Model (PDM). In PDM, the aggression process of chloride ions for passive film was described as chloride absorbs into surface oxygen vacancies at bl/outer layer (ol) interface and extract a cation in an autocatalytic process that leads to the continual generation of cation vacancies that are then migrate across the bl to condense at the metal/bl interface to separate the bl from substrate.
(1) The band gap of passive film narrows with introducing chloride into the electrolyte, where VBM increased significantly from photo-electrochemical and UPS measurements.
(2) DFT calculations indicated that only copper vacancy in the oxide model could increase the VBM, while oxygen vacancy and chloride-occupied oxygen vacancy just result in a decrease in CBM.
(3) The combining results verified that an increase of copper vacancy concentration in passive film would be substantial indeed owing to the participation of chloride ions, which is consistent with the description of aggression role of Cl− on the initial breakdown of passive film in PDM where Cl− in solution could extract cation vacancy in the barrier layer of the passive film by interacting with a surface oxygen vacancy.
| This journal is © The Royal Society of Chemistry 2019 |