Ville
Miikkulainen
a,
Ola
Nilsen
*a,
Mikko
Laitinen
b,
Timo
Sajavaara
b and
Helmer
Fjellvåg
b
aCentre for Materials Science and Nanotechnology (SMN), Department of Chemistry, University of Oslo, P.O. Box 1126, Blindern, NO-0318 Oslo, Norway. E-mail: ola.nilsen@kjemi.uio.no
bDepartment of Physics, FI-40014 University of Jyväskylä, P.O. Box 35, Finland
First published on 8th March 2013
Atomic layer deposition (ALD) was employed to deposit ternary films of LixTiyOz. The film growth at a deposition temperature of 225 °C was studied using both titanium tetra-isoropoxide (Ti(OiPr)4) and titanium tetrachloride (TiCl4) as titanium precursors. Lithium tert-butoxide (LiOtBu) was applied as the lithium source and water was used as the oxygen source for all metal precursors. The type of titanium precursor chosen strongly affected film growth: with TiCl4 the resulting LixTiyOz films were highly air-sensitive and the lithium concentration was low, whereas with Ti(OiPr)4 the films were relatively stable in air and with a lithium content which was easily controlled over a wide range. Film characterization indicated that part of the lithium in the film migrated onto the surface and formed carbonates. Films with suitable lithium contents crystallized into the spinel Li4Ti5O12 structure upon post-deposition annealing.
Thin film batteries have so far mainly been prepared by physical vapor deposition (PVD) methods, such as magnetron sputtering and pulsed laser deposition.1 These are line-of-sight methods limiting the film stack to planar geometry. However, if the film stack was deposited onto a three dimensional substrate, the footprint capacity would significantly increase. Realization of such 3D battery structures would, on the other hand, require much thinner electrodes in the form of films. This would again lead to an improved high rate performance due to shorter ionic and electronic diffusion paths.2–4
With atomic layer deposition (ALD) highly conformal films can be deposited onto complex three dimensional substrates.5 Film growth by ALD is based on successive pulses of precursor vapors that react with the surface in a self-limiting manner. The precursor pulses are separated by inert gas or evacuation purges to prevent gas phase reactions. A fully surface controlled growth enables an accurate control over the film thickness and its composition in addition to a highly conformal nature of the deposited films. Recently, ALD has been introduced as an enabling method for all-solid-state 3D lithium ion batteries.6 The unique properties of ALD exceed the limitations of the state-of-the-art thin film battery fabrication methods. Lithium is obviously a fundamental component of lithium ion batteries, yet the field of lithium containing materials is quite new to ALD as the number of reported processes is limited.7–13
Lithium titanate spinel, Li4Ti5O12 (LTO), has many advantageous properties especially suitable for all-solid-state cells.14 LTO's cubic (Li1/3Ti5/3)O4 framework enables an isotropic lithium diffusion which cancels out the film orientation effects on battery kinetics. Moreover, its volume change upon electrochemical cycling is only 0.3%, which is crucial in a rigid film stack to prevent the film from cracking and peeling off. The intercalation reaction of LTO, yielding a theoretical capacity of 175 mA h g−1, is demonstrated by eqn (1):
Li4Ti5O12 + 3Li+ +3e− ↔ Li7Ti5O12 | (1) |
In the present study we combined the TiO2 and Li2O–LiOH binary ALD processes to prepare the LixTiyOz ternary material. For the TiO2 subcycle we studied the effect of alkoxide and chloride based chemistries on LixTiyOz growth. We found that the chloride-based process yielded low concentrations of lithium in the film, whereas with an alkoxide based process the composition of the film can be controlled over a wide range by altering the Li2O–LiOH:
TiO2 pulsing ratio. With an appropriate pulsing ratio, the LTO phase was found in the as-deposited film and the crystallinity of the film improved upon annealing.
Film thicknesses were characterized with spectroscopic ellipsometry (Woollam Alpha SE) by applying the Cauchy model for LTO films. The crystallinity of the films was studied with a Bruker AXS D8 powder diffractometer equipped with a Ge(111) monochromator providing Cu Kα1 radiation and using a LynxEye detector. Compositional analyses were made with both time-of-flight elastic recoil detection analysis (TOF-ERDA) and photoelectron spectroscopy (XPS, Kratos Axis UltraDLD). In the TOF-ERDA measurements an 8 MeV 35Cl or 79Br beam from a Pelletron accelerator bombarded the sample and the energy spectra of the forward scattered particles were used as the basis of the elemental depth profiles. With TOF-ERDA all the atoms of the samples, including hydrogen, can be quantitatively depth profiled.
![]() | ||
Fig. 1 Film growth per cycle and Li![]() ![]() ![]() ![]() |
The elemental composition of a 97 nm film deposited with a 1:
1 Li
:
Ti pulsing ratio from TiCl4 is tabulated in Table 1. The amount of chlorine is at the same level as reported for pure TiO2 films deposited from TiCl4 at the temperature of 225 °C.21 In contrast, the amount of hydrogen and carbon is notable in the film. LixTiyOz films deposited with TiCl4 were amorphous as studied by XRD.
Element | Atomic % ± error |
---|---|
O | 58 ± 4 |
Ti | 23 ± 2 |
H | 8 ± 2 |
C | 5 ± 1 |
Li | 5 ± 1 |
Cl | 1.1 ± 0.2 |
Na | 0.22 ± 0.05 |
N | <0.1 |
Aaltonen et al. recently published an ALD process for lithium lanthanum titanate (LLT) based on TiCl4–water, LiOtBu–water and La(thd)3–ozone for TiO2, LiOH–Li2O and La2O3 subcycles, respectively.7 In other words, the LLT process employs the same precursor chemistries for TiO2 and LiOH–Li2O as our LixTiyOz process described in the previous paragraphs. In case of LLT, if the lithium subcycle was introduced after the titanium subcycle, the films were less uniform than if the lithium was introduced after the lanthanum subcycle. In the latter case, the films were uniform and air-stable. The lithium concentration was quite high for both cases compared to our findings. Aaltonen et al. however, found that the addition of successive lithium subcycles did not increase the lithium content in the films, contrary to what one would expect. It was concluded that the substrate surface is more reactive towards LiOtBu after a lanthanum subcycle than it is after a lithium subcycle. Similar factors may explain the unexpected low lithium concentrations in the LixTiyOz films employing TiCl4 as well.
Since lithium was found to be difficult to incorporate into the film and the films were air-sensitive, further studies on LixTiyOz depositions employing TiCl4 as a titanium source were postponed at this point.
![]() | ||
Fig. 2 Film growth per cycle and the Li![]() ![]() ![]() ![]() ![]() ![]() ![]() ![]() |
The hygroscopic nature of lithium-containing ALD films has been frequently reported.7,9,11,13 For Li–Al–O films it was observed that water physisorbs rather heavily into the growing film even when used as a precursor.9In situquartz crystal microbalance analysis showed that if the purge time after the water pulse was elongated, the amount of water decreased but was not completely removed within a reasonable purging time. Nevertheless, the self-limiting nature of film growth was verified and a seemingly small amount of physisorbed water is allowed to still maintain the surface-controlled growth.9
For the same pulsing ratios, the lithium content in the film is much higher with the Ti(OiPr)4-based process than with the TiCl4-based one, as can be seen from Fig. 1 and 2. At the same time, growth per cycle does not increase for the Ti(OiPr)4-based process as much as for the chloride-based process when the Li:
Ti pulsing ratio is increased. It should also be noted that the lithium concentration range accessible with the Ti(OiPr)4-based process is wide. The film uniformity was very good regardless of the lithium concentration. These films react with air as well, but within a time ranging from weeks to months depending on lithium concentration. Films became milky starting from the edges upon reaction with air.
To verify the surface-controlled, self-limiting nature of film growth, the pulse saturation of LiOtBu was studied. The pulsing sequence was N × [2 × {Ti(OiPr)4(10 s pulse/5 s purge) + H2O(1/5)} + {LiOtBu(X/12) + H2O(1/8)}]. The pulse length was varied and the growth per cycle and lithium concentration were characterized. Pulse saturation results are shown in Fig. 3, proving a saturation of the LiOtBu pulse close to four seconds, which is lower than the eight second pulses applied throughout the study.
![]() | ||
Fig. 3 Lithium content (TOF-ERDA) and growth per cycle of a LixTiyOz film deposited with Ti(OiPr)4 as the titanium source (1![]() ![]() ![]() ![]() |
Concentration (atomic %) ± error | |||
---|---|---|---|
Element | 1![]() ![]() ![]() ![]() |
1![]() ![]() ![]() ![]() |
2![]() ![]() ![]() ![]() |
Ti | 28 ± 1 | 21 ± 1 | 3.2 ± 0.3 |
Li | 10 ± 1 | 25 ± 1 | 28 ± 2 |
O | 58 ± 3 | 52 ± 2 | 48 ± 3 |
H | 3.0 ± 0.5 | 1.7 ± 0.2 | 5.5 ± 1.0 |
C | 0.5 ± 0.2 | 0.09 ± 0.05 | 14 ± 2 |
N | <0.05 | <0.05 | — |
Na | 0.07 ± 0.04 | 0.18 ± 0.04 | 0.5 ± 0.1 |
The oxygen off-stoichiometry and the high levels of contamination concentrations may be due to either the less favorable chemistry at a high Li:
Ti pulsing ratio, leaving unreacted ligands in the film during its growth, or the increased reactivity of the film towards air. The sodium concentration increases along with the lithium concentration and most probably originates from impurities in the LiOtBu precursor. The sodium content is however low even in the film with the highest lithium content.
The elemental depth profile for an 89 nm film deposited with a 1:
2 Li
:
Ti pulsing ratio is presented in Fig. 4. The bulk of the film is homogeneous with respect to all its constituent elements. The carbon concentration is very low inside the film but clearly peaks on the film surface. Hydrogen is also enriched on the surface.
![]() | ||
Fig. 4 Elemental TOF-ERDA depth profile of an 89 nm film deposited with a 1![]() ![]() ![]() ![]() |
Li:
Ti concentration ratios were also studied with XPS similarly to what was done with TOF-ERDA. Quantifications were based on the Li1s, O1s, and Ti2p peak integrals. The LTO reference sample gave a stoichiometry of Li4.1Ti5.0O12 validating the quantification method. Li
:
Ti ratios obtained for the ALD-films differed from the values based on TOF-ERDA data. For the TiCl4-originated film, XPS gave a Li
:
Ti ratio of 0.48 while the Li
:
Ti ratio for the Ti(OiPr)4-based film was 1.82. These values are much higher than the corresponding values obtained from the film bulk with TOF-ERDA shown in Fig. 1 and 2 (0.18 and 0.3, respectively). This supports the conclusion that lithium is enriched on top of the film. The same effect is found with both ALD chemistries. The magnitude of the enrichment seems to be much higher in the case of Ti(OiPr)4 but there are probably several other parameters than just the precursor chemistry influencing it. These may include the overall lithium concentration in the film and exposure time to ambient air, among others.
The amount of carbonates and the lithium enrichment were both found to be low for the powder reference. Lack of a lithium enrichment is most probably due to the stoichiometric and polycrystalline nature of the material. In less ordered, off-stoichiometric structures of the ALD materials the lithium ions are most likely more mobile than in the polycrystalline Li4Ti5O12 reference.
Silicon is well-known for its redox reactions with lithium ions.24 Therefore a diffusion barrier, such as platinum, is needed between the silicon substrate and the LTO films to prevent silicon from reacting with the lithium ions if the electrochemical studies are conducted on the sample. Films were deposited on platinum coated silicon also for XRD analysis to have a good correlation between the film microstructure and the electrochemical characteristics. Platinum is also a widely applied current collector for battery electrodes. The sample was a 110 nm film deposited using a 2:
3 Li
:
Ti pulsing ratio which should yield a deposited Li
:
Ti ratio of 1.5 (Fig. 2). This is higher than the 0.8 expected for stoichiometric LTO. A higher value for the Li
:
Ti ratio was selected to compensate for the lithium diffusion onto the surface and carbonate formation as well as possible lithium loss during annealing. X-Ray diffractograms for as-deposited and annealed films are presented in Fig. 5. The annealing was performed in a rapid thermal processing (RTP) oven (MTI corporation, USA) under a nitrogen atmosphere for five seconds.
![]() | ||
Fig. 5 X-ray diffractograms for as-deposited (black, bottom), 640 °C annealed (red, middle), and 700 °C annealed films (green, top). The black tick-marks below the graphs correspond to spinel Li4Ti5O12 (JCPDS 49-0207), the blue to anatase TiO2 (JCPDS 21-1272) and the red to rutile TiO2 (JCPDS 01-078-2485). Indexing refers to spinel Li4Ti5O12. Reflections from the substrate are marked with an asterisk. |
For all of the three studied samples, the only crystalline phase arising from the film is spinel LTO. Neither rutile nor anatase, the most common impurities in LTO syntheses,25,26 are visible. The LTO reflections become stronger when the film is annealed indicating film crystallization. The film is somewhat [100] oriented since (111) would be the strongest reflection in the powder standard 49-0207. Films prepared by other methods have been reported to be [111] oriented.15–17
Footnote |
† Electronic supplementary information (ESI) available: X-ray photoelectron spectra for LixTiyOz films. See DOI: 10.1039/c3ra40745d |
This journal is © The Royal Society of Chemistry 2013 |