Microbial transformations of 4′-methylchalcones as an efficient method of obtaining novel alcohol and dihydrochalcone derivatives with antimicrobial activity

Biotransformations are an alternative method of receiving dihydrochalcones as a result of the reduction of α,β-unsaturated ketones – chalcones. In presented research, two strains of bacteria – Gordonia sp. DSM44456 and Rhodococcus sp. DSM364 – were selected as effective biocatalysts that are able to transform chalcones in a short period of time. As a result of our investigation 3 new dihydrochalcones and one novel alcohol were obtained with high isolated yields. All 4′-methylchalcone derivatives and biotransformations products were tested for antimicrobial activity against Escherichia coli ATCC10536, Staphylococcus aureus DSM799, Candida albicans DSM1386, Alternaria alternata CBS1526, Fusarium linii KB-F1, and Aspergillus niger DSM1957. The best inhibitory effect was observed for all chalcones against E. coli ATCC10536 – compounds 1–6 and 8 prevented thorough growth of this strain (ΔOD = 0). Moreover, dihydrochalcones showed about 2–3 times stronger inhibitory effect against S. aureus DSM799 in comparison to their chalcones. Excluding the E. coli ATCC10536 strain, 3-(4-carboxyphenyl)-1-(4-methylphenyl)propan-1-ol (8b) had weaker biological activity than 4-carboxy-4′-methyl-α,β-dihydrochalcone (8a).


Introduction
Chalcones (1,3-diaryl-2-propen-1-ones) belong to a wide group of polyphenols known as avonoids.Their chemical structure is characterized by the a,b-unsaturated bond formed as the result of opening ring C in avanones. 1The presence of numerous electron-withdrawing or donating groups allows to describe chalcones as compounds with various biological activities such as anti-inammatory, 2 antioxidant, 3 antibacterial 4 and antitumor. 5,6ydrogenation of the a,b-unsaturated bond in chalcones leads to derivatives called dihydrochalcones.Interestingly, neohesperidin occurring in citrus fruits is characterized with a bitter taste in contrast to the neohesperidin dihydrochalconehypocaloric sweetener accepted by the EU and FDA as a food additive. 7Furthermore, antioxidant properties of dihydrochalcones were observed to be signicantly stronger than corresponding avanones. 8Moreover, many potential anticancer agents have already been found among chalcones.For example, 2 0 ,6 0 -dihydroxy-4 0 4-dimethoxydihydrochalcone, 2 0 ,6 0 -dihydroxy-4 0 -methoxydihydrochalcone and 2 0 ,4 0 ,6 0 -trihydroxydihydrochalcone (phloretin) augmented apoptosis in prostate cancer cells. 9ccording to literature, the chemoselective reduction of the a,b-unsaturated bond is the result of hazardous reagentssome of them requiring transition metals for reaction. 10,11Microbial transformations are a good alternative to chemical synthesis, transforming chalcones into dihydrochalcones without using harmful and toxic compounds.Also, the application of whole cells of microorganisms is oen superior to enzymatic modications, that usually are more costly, and need additional cofactors and strict incubation conditions.Moreover, multistep reactions, impeded by the traditional approach of chemical synthesis, are possible with the enzymatic apparatus of microbials.
The most frequently described modications of avonoids catalysed by microbial cells are hydroxylation, dehydroxylation, O-methylation, O-demethylation, glycosylation, deglycosylation, dehydrogenation, hydrogenation, C ring cleavage, cyclization and reduction. 12Enoate reductase has been characterised as one of the main enzymes responsible for reduction carboncarbon double bonds.It belongs to the Old Yellow Enzyme (OYE) family, consisting of the avin-dependent oxidoreductases, that require NADH to be active. 13Current knowledge proofs the presence of enoate reductases in known biocatalysts such as bacteria and fungi strains. 14,15Additionally, recent a report described the bioconversion of trans-chalcone by whole cells of cyanobacteria. 16This variety of active whole-cell catalysts creates a possibility of obtaining novel derivatives with enhanced biological properties.In recent years, antimicrobial activity of avonoids has gained much interest.Infections caused by microorganisms are one of the most important problems in all aspects of our life, especially in schools, hospitals and workplaces.Increasing resistance of microorganisms to commonly used antibiotics encourages the exploration of novel active compounds, oen from natural sources.The variety of chalcones and dihydrochalcones derivatives can hinder bacteria growth, including multi-resistant strains. 4,17Phloretin and their glycosylated derivativesphlorizin and phloretin 3 0 ,5 0 -di-C-glucosideare known growth inhibitors of Gram-positive bacteria such as Staphylococcus aureus ATCC6538, clinical strains of methicillin-resistant Staphylococcus aureus (MRSA) and Listeria monocytogenes ATCC13932.Furthermore, phloretin showed antibacterial activity against Gram-negative bacteria -Salmonella typhimurium ATCC13311. 18Also, the investigation performed by a scientic group in Brazil showed that 4-methoxy-4 0 -methylchalcone (3) hindered the growth of Gram-positive bacteria Mycobacterium tuberculosis H37Rv with a MIC 50 value of 66.9 mM. 19n our paper, we describe microbial transformation of series of 4 0 -methylchalcone derivatives (1-8) performed by two species of aerobic bacteria -Gordonia sp.DSM44456 and Rhodococcus sp.DSM364.Previous experiments carried out by our research team allowed us to select two strains of bacteria capable of transforming chalcones to dihydrochalcones with high isolated yields. 14Moreover, we observed that elongation of biotransformation time provides a second metabolite: the alcohol.Subsequently, an evaluation of antimicrobial activity against six strains of microorganisms Escherichia coli ATCC10536, Staphylococcus aureus DSM799, Candida albicans DSM1386, Alternaria alternata CBS1526, Fusarium linii KB-F1, and Aspergillus niger DSM1957 was prepared for synthetized chalcones (1-8) and compared with their biotransformation products (1a-8a, 8b).

Experimental
Materials All 4 0 -methylchalcone derivatives (1-8) were prepared with the procedure described by Amir et al. with yield 60-94%. 20 Biotransformations were performed using two strains of bacteria -Gordonia sp.DSM44456 and Rhodococcus sp.DSM364.Strains were obtained from the German Collection of Microorganisms and Cell Cultures GmbH (DSMZ, Deutsche Sammlung von Mikroorganismen und Zellkulturen, GmbH).

Biotransformation in small scale
Screening procedure was performed in Erlenmeyer asks (100 mL) containing 25 mL of culture medium, which consisted of 10 g peptone, 2 g casein hydrolysate, 2 g yeast extract, 6 g sodium chloride and 20 g glucose dissolved in 1000 mL distilled water.Sterile culture medium was inoculated using 0.1 mL of bacteria suspension and kept at 28 C on rotary shaker.Aer 48 hours, 1 mg of 4 0 -methylchalcone derivative dissolved in 0.5 mL acetone (1-7) or dimethyl sulfoxide (DMSO) (8) was added to the culture.Progress of biotransformation was monitored by the thin layer chromatography (TLC) and the liquid highperformance chromatography (HPLC).

Biotransformation in preparative scale
To isolate products of biotransformation observed in small scale, preparative investigation was performed using 2000 mL Erlenmeyer asks containing 300 mL of sterile culture medium, inoculated with 1 mL of bacteria suspension and maintained at 28 C on rotary shaker.Aer 48 hours 30 mg of 4 0 -methylchalcone derivative dissolved in 1 mL acetone (1-7) or DMSO (8)  was added to the grown culture and incubation under the same conditions was continued.Aer determining the complete substrate conversion, biotransformation mixture was extracted with ethyl acetate (3 Â 100 mL).Organic fractions were collected and dried over anhydrous sodium sulphate.Organic solvent was evaporated on vacuum evaporator and biotransformation extract was puried on column chromatography.Purity of obtained products was veried by HPLC and structures were determined using 1 H and 13 C NMR.

Analytical methods
Progress of biotransformations performed in small and preparative scale was analysed by thin layer chromatography (TLC) on silica gel-coated aluminium plates with uorescent indicator (DC-Alufolien, Kieselgel 60 F 254 ; Merck, Darmstadt, Germany) using mixture of hexane : ethyl acetate or chloroform : methanol as eluents.Products were detected by spraying the plates with a solution of 1% Ce(SO 4 ) 2 and 2% H 3 [P(Mo 3 O 10 ) 4 ] in 5% H 2 SO 4 and subsequently visualised by heating.Extracts obtained from preparative biotransformations were puried by liquid column chromatography using silica gel (Kieselgel 60, 230-400 mesh, Merck).The purity of the products was analysed by HPLC on a Waters 2690 (Milford, MA, USA) with Photodiode Array Detector Waters 996.The samples of substrates and biotransformation products for HPLC analysis were dissolved in methanol.The HPLC apparatus was equipped with a reverse-phase C-18 column (Phenomenex, Torrance, CA, United States, Kinetex 5u XB-C18 100A, 250 mm Â 4.6 mm), which was thermostated at 28 C, and analysed samples were kept at 12 C.The mobile phase consisted of two eluents: A-1% HCOOH in MeCN and B-1% HCOOH in H 2 O. Elution gradient was started from 55% of eluent A to 45% of eluent B over 15 min.A ow rate of 1.5 mL min À1 was used.
The structure of the obtained compounds was conrmed using nuclear magnetic resonance (NMR) analysis. 1H-NMR and 13 C-NMR spectra were recorded on a Bruker Avance™600 MHz spectrometer (Bruker, Billerica, MA, USA) with chloroform-d as solvent.
Positive and negative-ion HR ESI-MS spectra were measured on a Bruker ESI-Q-TOF Maxis Impact Mass Spectrometer (Bruker, Billerica, MA, USA).The direct infusion of ESI-MS parameters: the mass spectrometer was operated in positive (1a-8a) and negative (8b) ion mode with the potential of 3.5 kV between the spray needle and the orice, nebulizer pressure of 0.4 bar, and a drying gas ow rate of 3.0 L min À1 at 200 C.The sample ow rate was set as 3.0 mL min À1 .Ionization mass spectra were collected at the ranges m/z 50-1250.
Infrared spectra were determined using a Nicolet 6700 FTIR spectrometer (Thermo Scientic, Waltham, MA, USA) with ATR accessory with diamond crystal in the wavelength range 400-4000 cm À1 .
Optical rotation was measured on Jasco P-2000 automatic polarimeter (ABL&E-JASCO, Kraków, Poland).Solution was prepared in chloroform and the concentration was expressed in g/100 mL.

Biological assays
To evaluate activity of 4 0 -methylchalcones and their derivatives obtained as a result of biotransformations, a series of antimicrobial assays were performed.In our investigation two strains of bacteria: E. coli ATCC10536 and S. aureus DSM799 and four strains of fungi: C. albicans DSM1386, F. linii KB-F1, A. alternata CBS1526 and A. niger DSM1957 were used.All the microorganisms were obtained from the collection of the Faculty of Biotechnology and Food Microbiology, Wroclaw University of Environmental and Life Sciences.Bacteria were cultured in the standard nutrient broth (Biocorp, Warsaw, Poland), and fungi in the YM medium, which consisted of 3 g yeast extract, 3 g malt extract, 5 g bacteriological peptone and 10 g of glucose dissolved in 1 L of distilled water.Assays were performed on 100-well microtiter plates, with the working volume of 300 mL per well: 280 mL of culture medium, 10 mL of microorganism suspension and 10 mL of 4 0 -methylchalcone or its derivative dissolved in DMSO (0.3% (w/v)).The nal concentration of the tested substance was 0.1% (w/v).Each culture was prepared in triplicate.The optical density (OD) of the cell suspensions was measured on Bioscreen C (Automated Growth Curve Analysis System Lab System, Helsinki, Finland) at 560 nm automatically, at regular intervals of 30 min for 2-3 days.Cell cultures were maintained at 28 C on a continuous shaker.The growth curves for each strain were prepared as a mean values of the measured OD as a function of time.The resulting antimicrobial activity was expressed as the increase in optical density (DOD) in comparison to the control cultures in the medium supplemented with dimethyl sulfoxide.

Biotransformations
Chalcones received in classical Claisen-Schmidt reaction were used as a substrate to biotransformation.
Current literature describes the biotransformation of 4 0methylchalcone (1) to dihydrochalcone (1a) in Corynebacterium equi IFO 3730 culture aer 3 days with 94% yield. 21owever, our investigation have showed complete conversion of all substrates (1-8) already aer maximum 24 hours with isolated yields up to 99%.Microbial transformations were monitored in time using thin layer chromatography and highperformance liquid chromatography.Aer the disappearance of the substrate, extraction and purication on liquid chromatography gave us pure product.The structure of all the compounds was determined by nuclear magnetic resonance analysis.Biotransformations of substrates 1-7 resulted in obtaining their dihydrochalcones (Scheme 1).Interestingly, the product of 4-carboxy-4 0 -methylchalcone (8) transformation under the same cultivation condition appeared to be the alcohol (8b), not the expected dihydrochalcone.hour was 4-carboxy-4 0 -methyl-a,b-dihydrochalcone (8a).The presence of electron withdrawing group (e.g.carboxylic, nitro group) usually enhance the rate of hydrogenation catalyzed by enoate reductase. 22However, accelerated process of biotransformation was observed only in the case of 4-carboxy-4 0methylchalcone (8).Most likely, the effect of action was connected with better solubility of substrate or uptake by microorganism cells caused by presence of carboxylic group. 23he efficiency of microbial transformation in Gordonia sp.DSM44456 and Rhodococcus sp.DSM364 culture described Table 1.

Spectral data of biotransformation products
The structures of biotransformation products were determined by 1 H-NMR, 13 C-NMR and HR ESI-MS analysis.Additionally, FTIR-ATR spectra of novel compounds were recorded.All data are described in details below.Broad spectrum of biological properties of chalcones and their derivatives is associated with the diversity of these polyphenolic compounds.Chalcones and dihydrochalcones belong to secondary plant metabolites and constitute a natural protective barrier against microbial infections.Phloretin is one of the most popular dihydrochalcones exhibiting strong antimicrobial activity against Erwinia amylovora and Venturia inaequalis -Gram-negative bacteria and fungus, which are a common cause of apple diseases. 28s a result of our investigations, antimicrobial activity of synthesised chalcones (1-8) and biotransformation products (1a-8a, 8b) was characterized.Inhibitory effect of all compounds was evaluated against two strains of bacteria and four strains of fungi (Tables 2 and 3).
Previously, Stompor et al. tested antibacterial activity of 4 0methoxychalcone derivatives against E. coli PCM2560, S. aureus PCM2054 and C. albicans KL-1 using agar diffusion method with 10 mL of 20% (m/v) compounds applied onto each test disc.They reported, that chalcones with methoxy group attached to the C-4 0 position had no bacteriostatic effect on E. coli PCM2560. 29As a result of our study, complete inhibition of growth of E. coli ATCC10536 in presence of compounds 1-6 and 8 was observed.Contrarily, 4 0 -methyl-4-nitrochalcone (7)  enabled the limited growth of this strain of bacteria (DOD ¼ 0.31) and additionally caused prolongation of the lag phase from 4 to 22 hours.Sivakumar et al. calculated the Minimal Inhibitory Concentration (MIC) of 4-methoxy-4 0 -methylchalcone against S. aureus NCIM5021 at the level of 0.248 mM.Unfortunately, this activity is three times weaker than the popular antibiotic ampicillin. 30In our research, 4 0 -methylchalcone derivatives with alkyl, O-alkyl or nitro group attached to the C-4 position, also exhibited a very weak effect considering limitation of S. aureus DSM799 growth, but they prolonged the adaptive phase from 3 to 23.5-26.0hours.However, 2,4-dimethoxy-4 0 -methylchalcone (4) exhibited activity that was twice as strong as the chalcone without methoxy group attached to the C-2 position (3).A similar effect was observed for 4-carboxy-4 0methylchalcone, which also extended the lag phase of S. aureus DSM799.López et al. reported that 4-methoxy-4 0 -methylchalcone (3) exhibited strong inhibitory activity against two dermatophytes fungi Microsporum canis C112 and Epidermophyton occosum C114 with the MIC value of 3 mg mL À1 and 0.5 mg mL À1 , respectively.In contrast, antifungal activity against C. albicans, Saccharomyces cerevisiae, Cryptococcus neoformans, Aspergillus niger, A. fumigatus and A. avus was not observed. 31In the case of C. albicans DSM1386 we noted the same lack of response to the chalcone 3 and also to the other alkyl (methyl and ethyl) derivatives (1, 2, 5).Partial growth inhibition in the presence of 4-ethoxy-4 0 -methylchalcone was identied.Furthermore, 2,4-dimethoxy-4 0 -methylchalcone limited the proliferation of C. albicans DSM1386 (DOD ¼ 0.63).As a result of 4-carboxy-4 0 -methylchalcone action, high inhibition of C. albicans DSM1386 (DOD ¼ 0.29) and F. linii KB-F1 (DOD ¼ 0.32) growth was observed.Moreover, this derivative provided total inhibition of growth of A. alternata CBS1526 and A. niger DSM1957.
Compounds 4a and 8a demonstrated the same inuence on growth of this strain, but alcohol 8b exhibited weaker effect of action in comparison to dihydrochalcone 8a.Evaluation of antimicrobial activity allowed us to compare biological properties of synthesised compounds with their corresponding derivatives achieved as a result of microbial transformation.Chalcones 1-6, 8 and novel alcohol 8b exhibited the highest inhibitory effect against E. coli ATCC10536 (DOD ¼ 0).In the case of S. aureus DSM799, dihydrochalcones showed 3 times stronger inhibitory activity than corresponding chalcones.Also, dihydrochalcones expressed higher antifungal activity against C. albicans DSM1386.In the case of A. alternata CBS1526, F. linii KB-F1 and A. niger DSM1957 chalcones and dihydrochalcones demonstrated similar activity, excluding 4carboxy-4 0 -methyl-a,b-dihydrochalcone (8a), which caused complete inhibition of growth A. niger DSM1957 (DOD ¼ 0).