Open Access Article
Tatsuo Kimura
*
National Institute of Advanced Industrial Science and Technology (AIST), Sakurazaka, Moriyama-ku, Nagoya 463-8560, Japan. E-mail: t-kimura@aist.go.jp
First published on 22nd May 2024
The morphology of surfactant-assisted mesoporous metal oxides was tuned to obtain high surface-area particles by utilizing the synthetic conditions for fabricating transparent thin films through an evaporation-induced self-assembly (EISA) process. For investigating their potential applications, especially for designing heterogeneous catalysts, mesoporous metal oxides should be obtained in powder forms; however, a serious limitation associated with their reproducibility persists. Herein, along with a rapid optimization approach, starting from determining and improving chemical composition for the fabrication of mesoporous metal oxide films, an advanced approach to obtain highly porous metal oxide powders is presented using a temperature-controlled spray-drying process with step-by-step but smooth optimization by combining several EISA processes, involving the utilization of a precursor solution optimized for a slow-drying process in the case of ceria (CeO2) using poly(styrene)-block-poly(ethylene oxide) (PS-b-PEO).
A wide variety of mesoporous metal oxide powders have thus far been prepared using surfactants by room-temperature slow drying and temperature-controlled fast spray-drying precursor solutions. Both EISA processes need long working times to investigate all the synthetic conditions, including the chemical composition of each precursor solution. From this viewpoint, our approach for obtaining high-quality mesoporous metal oxide powders is quite beneficial for the smooth optimization of synthetic conditions by combining several EISA processes. By utilizing the synthetic conditions for fabricating an ordered mesoporous metal oxide film, the chemical composition of a precursor solution can be determined very quickly via a rapid spin-coating process with fast evaporation of solvents. The same precursor solution is then applied to the fast spray-drying process and optimized further for increasing the resultant porosity. According to this realistic approach, we can save much of the working time for optimizing chemical composition, which has already been demonstrated through the synthesis of porous Al2O3 powders using poly(styrene)-block-poly(ethylene oxide) (PS-b-PEO).14–16
In this study, this synthetic approach was enhanced further as a useful choice for optimizing the chemical composition of a precursor solution very smoothly for obtaining aerosol-assisted metal oxide powders with surfactant-assisted mesopores. A precursor solution optimized for recovering mesoporous metal oxide powders by the room-temperature drying process with a slow evaporation of solvents was applied for the synthesis of the corresponding films by spin-coating. After finding the molecular structure of PS-b-PEO with the best potential for obtaining ordered and/or highly porous films, the corresponding powders were recovered by the spray-drying process (see Scheme 1). This step-by-step but smooth optimization by combining several EISA processes was proved for the synthesis of highly porous ceria (CeO2) powders in the presence of amphiphilic organic compounds, such as PS-b-PEO. This is a significant advance as a time-saving approach to obtain high-quality mesoporous metal oxide powders, which could be potentially started from the chemical compositions found in a huge number of research papers on obtaining room-temperature drying powders of mesoporous metal oxides.
000-b-19
500, 10
000-b-21
000, 12
200-b-23
900, 16
000-b-7500, 16
400-b-39
500, 18
000-b-7500, 18
000-b-39
000, 35
000-b-17
000, 40
000-b-25
500, 40
000-b-31
000, 40
000-b-40
500, 40
000-b-53
000, 51
000-b-28
000, 53
000-b-15
000, 58
500-b-37
000, 58
600-b-71
000, 59
000-b-31
000, 59
000-b-72
000, 60
000-b-18
000, 60
000-b-36
000, 60
000-b-61
000, 60
000-b-85
000, 65
000-b-85
000, 65
000-b-97
000, 90
000-b-45
000, 100
000-b-150
000, 105
000-b-155
000, 116
000-b-164
000, and 125
000-b-177
000.
000-b-7500 and 59
000-b-31
000, were found for obtaining high-quality porous CeO2 films (see (a) and (d) in Fig. 1). The pore diameters after calcination at 400 °C were estimated to be ∼20 nm and ∼35 nm by SEM, respectively. Besides, the molecular structures having PS > PEO (e.g., 35
000-b-17
000 and 40
000-b-25
500) seemed useful for the formation of spherical pores, but much larger pores could not be structured in resultant films thinner than the pore diameters. Scratched off powders of the CeO2 films prepared using 16
000-b-7500 and 59
000-b-31
000 were characterized by TEM (see (b) and (e) in Fig. 1), revealing the presence of large-sized mesopores surrounded by nanoparticles of CeO2 crystallized to its cubic phase with the space group Fm
m.18–21 Interestingly, their particle size was almost homogeneous throughout the mesoporous CeO2 films, with the average size of around 3 nm (see (c) and (f) in Fig. 1).
In the process of the soft-templating of mesoporous CeO2 using amphiphilic organic compounds,22 a hydrogenated poly(butadiene)-block-poly(ethylene oxide) (PHB-b-PEO, named as KLE, H[CH2CH2CH2CH(CH2CH3)]n(OCH2CH2)mOH with a molecular weight of 4400-b-3920 g mol−1) was the most successful one for obtaining an ordered mesoporous CeO2 film.18 KLE is one of the famous amphiphilic organic compounds for obtaining a wide variety of metal oxides containing large-sized spherical mesopores.23 In the case of CeO2, the formation of large-sized mesopores (14 nm and more) was confirmed by TEM and the mesoporous structure was maintained even after crystallization of the CeO2 frameworks by calcination at 550 °C.18 In the synthesis of mesoporous CeO2 films using Pluronic P123 (EO20PO70EO20), which is a commercially available EOnPOmEOn type triblock copolymer, the aging time of the CeO2 sol, the relative humidity during dip-coating, and the calcination temperature were very important for tuning the size of the CeO2 nanocrystals that should be accommodated inside the limited space of the thin CeO2 frameworks around the EOnPOmEOn micelles.24 Compared to the size of the resultant micelles of the asymmetric KLE and symmetric Pluronic P123, KLE seemed preferable for accommodating large-sized mesopores with the formation of thick CeO2 frameworks. In this study, the high-molecular-weight PS-b-PEO type amphiphilic organic compounds were asymmetric and thus useful for obtaining large-sized mesoporous CeO2, as in the case of other metal oxides.18,23,25–28
000-b-7500 (0.10 g) clearly showed the opening of PS-b-PEO-templated large-sized mesopores throughout the CeO2 particles after calcination at 400 °C (see (a) in Fig. 2). The morphology seemed different from that observed for mesoporous metal oxide particles, which were typically aggregated as spherical ones, prepared by an aerosol-assisted synthesis using amphiphilic organic molecules.14–16,27 This was likely be due to the strongly ethanolic synthesis without water showing a high surface tension. The TEM images revealed that the PS-b-PEO-templated mesopores were surrounded by fine CeO2 nanoparticles (around 3 nm) (see (a) and (b) in Fig. 3). The N2 adsorption–desorption isotherm was almost type V (see (b) in Fig. 2) as indicated by the presence of large-sized mesopores.16,25–27 The BET surface area and the total pore volume were 160 m2 g−1 and 0.35 cm3 g−1, respectively.31 These extremely large values come from the presence of intercrystalline spaces of the resultant fine nanoparticles of CeO2 in addition to the surfaces of the PS-b-PEO-templated mesopores. Some diffraction peaks that could be assigned to the typical cubic Fm
m phase of CeO2 were clearly detected in the wide-angle XRD pattern (see (a) in Fig. 4).
![]() | ||
Fig. 3 TEM images of CeO2 powders prepared using (a and b) 0.10 g, (c and d) 0.12 g, and (e and f) 0.14 g of 16 000-b-7500 via spray-drying and calcination at 400 °C. | ||
![]() | ||
Fig. 4 XRD patterns of CeO2 powders prepared using (a) 0.10 g, (b) 0.12 g, and (c) 0.14 g of 16 000-b-7500 via spray-drying and calcination at 400 °C. | ||
In the early papers on the synthesis of mesoporous CeO2 samples using Pluronic P123, it was rather difficult to structure ordered mesopores by a drying process.29,30 Still, the mesoporous structure was stable after calcination below 500 °C (120–150 m2 g−1 after calcination at 400 °C and 80–110 m2 g−1 after calcination at 500 °C) even when the CeO2 frameworks were crystallized to the cubic Fm
m phase.19–21 The mesopores though were deformed and finally collapsed by further crystallization at around 600 °C and the grain growth of CeO2 nanocrystals at higher temperature.30 Large-sized mesopores that are surrounded by thick frameworks allow abundant crystallization and the extra phase transformation of metal oxide species.14–16 The use of preformed CeO2 nanocrystals (∼3 nm) is a suitable approach for obtaining mesoporous CeO2 powders using EOnPOmEOn smaller than KLE and PS-b-PEO (for example, 160 m2 g−1 and 0.35 cm3 g−1 after calcination at 500 °C).19,21,31 In summary, according to the added benefits of using PS-b-PEO, this study was very successful at obtaining highly porous powders structured by highly crystallized CeO2 nanocrystals.
The amount of 16
000-b-7500 was, besides, increased to 0.12 g and 0.14 g for checking the possibility to increase the porosity. The specific surface area and the total pore volume are summarized in Table 1, including those prepared using 0.10 g of 16
000-b-7500. The analytical data, such as the SEM images with the N2 adsorption–desorption isotherms, the TEM images, and the XRD patterns, are presented in Fig. 2–4, being almost analogous to those observed for the highly porous CeO2 particles prepared using 0.10 g of 16
000-b-7500. By increasing the amount of 16
000-b-7500, the BET surface area and the total pore volume gradually increased up to around 200 m2 g−1 and around 0.46 cm3 g−1, respectively. Likewise, the powder samples were synthesized by spray-drying precursor solutions containing different amounts of 59
000-b-31
000 (0.10 g, 0.12 g, and 0.14 g) at 140 °C and then calcined at 400 °C. The SEM images with the N2 adsorption–desorption isotherms, the TEM images, and the XRD patters are shown in Fig. 5–7, respectively. The resultant porosity (e.g., specific surface area and total pore volume) are listed in Table 1. Although the analytical data seemed similar to those observed for the CeO2 particles prepared using 16
000-b-7500, the BET surface area and the total pore volume were maximized to around 190 m2 g−1 and around 0.44 cm3 g−1 in the case of using 0.12 g of 59
000-b-31
000.
| PS-b-PEO | BET surface area/m2 g−1 | Total pore volume/cm3 g−1 | |
|---|---|---|---|
16 000-b-7500 |
0.10 g | 177 | 0.36 |
| 0.12 g | 197 | 0.44 | |
| 0.14 g | 202 | 0.46 | |
59 000-b-31 000 |
0.10 g | 169 | 0.36 |
| 0.12 g | 193 | 0.44 | |
| 0.14 g | 184 | 0.28 |
![]() | ||
Fig. 6 TEM images of CeO2 powders prepared using (a and b) 0.10 g, (c and d) 0.12 g, and (e and f) 0.14 g of 59 000-b-31 000 via spray-drying and calcination at 400 °C. | ||
![]() | ||
Fig. 7 XRD patterns of CeO2 powders prepared using (a) 0.10 g, (b) 0.12 g, and (c) 0.14 g of 16 000-b-7500 via spray-drying and calcination at 400 °C. | ||
Highly porous CeO2 powders (e.g., specific surface area of 200 m2 g−1 and total pore volume of 0.45 cm3 g−1, prepared using 16
000-b-7500 after calcination at 400 °C) were constructed by fine nanocrystals of CeO2 (around 3 nm) through a thermal calcination, being much higher than those synthesized using different amphiphilic organic compounds (pore size of 5.5 nm, specific surface area of 125 m2 g−1, and total pore volume of 0.20 cm3 g−1, prepared using EOnPOmEOn after calcination at 500 °C; and pore size of 12 nm, specific surface area of 87 m2 g−1, and total pore volume of 0.12 cm3 g−1, prepared using KLE after calcination at 500 °C).20,21 Even in the synthesis of pure CeO2 using the laboratory-made 17
000-b-5000, the specific surface area and total pore volume were limited to 107 m2 g−1 and 0.32 cm3 g−1 with the formation of ∼14 nm pores.17 Such nano-sized CeO2 crystallites are powerful materials for oxygen and charge storage32,33 and useful for the design of metal-supported catalysts that depend on strong interaction with the surfaces of crystallized CeO2 particles.34–36 For example, a strong interaction of Pt to nanostructured CeO2 surfaces is helpful for accelerating oxygen transfer from CeO2 to Pt, leading to the formation of Pt–O species.34 The size of CeO2 nanocrystals (several nm order) is important for controlling the catalytic performance of atomically dispersed palladium (Pd).36 The spray-pyrolysis technique is also very interesting for the design of single-atom catalysts over mesoporous metal oxides that are useful for low-temperature CO oxidation.37–40 The resultant CeO2 powders also possibly have potential for the design of metal-supported catalysts with an oxygen-storage capacity (OSC) for the purification of exhaust gases from automobiles.
000-b-7500 and 59
000-b-31
000), the same precursor solution was spray-dried at an appropriate temperature (e.g., 140 °C) for recovering high-quality porous CeO2 powders, and the porosity was checked and/or increased by changing the amount of PS-b-PEO. In addition to our previous approach starting from the synthetic conditions optimized by a fast spin-coating process,14 this extended approach to combine several EISA processes is promising for a smooth optimization of the synthetic conditions (e.g., the chemical composition of the starting mixture and the molecular structure of the amphophilic organic compound) for obtaining highly porous metal oxides. Numerous papers concerning the dried-up powders and spin-coated films of metal oxides would be helpful for reproducing highly porous metal oxide powders by this temperature-controlled spray-drying process in the presence of a wide variety of amphiphilic organic compounds.41,42
Footnote |
| † Electronic supplementary information (ESI) available. See DOI: https://doi.org/10.1039/d4ra01674b |
| This journal is © The Royal Society of Chemistry 2024 |