Open Access Article
Andres
Gonzalez-Garay
a,
Clara
Heuberger-Austin
b,
Xiao
Fu
b,
Mark
Klokkenburg
b,
Di
Zhang
ac,
Alexander
van der Made
*b and
Nilay
Shah
*a
aThe Sargent Centre for Process Systems Engineering, Imperial College London, SW7 2AZ London, UK. E-mail: n.shah@imperial.ac.uk
bShell Global Solutions International B.V., Shell Technology Centre Amsterdam, Royal Dutch Shell, 1031 HW Amsterdam, The Netherlands. E-mail: alexander.vandermade@shell.com
cCentre for Environmental Policy, Imperial College London, SW7 1NA London, UK
First published on 14th June 2022
The aviation industry is responsible for approximately 2% of the total anthropogenic greenhouse gas emissions. With an expected four to six-fold growth by 2050, increased attention has been paid to reduce its carbon footprint. In this study, we analyse the requirements to promote Sustainable Aviation Fuels (SAFs) from solar energy to reduce the emissions of the sector. Using a discrete spatio-temporal mathematical description of the region of Spain, we present the key elements required to produce jet fuel via Fischer–Tropsch (FT) and Methanol to fuels (MtF). We have found that solar PV, electricity storage, and alkaline water electrolysis are the key drivers for the performance of solar SAFs while the optimal location of the facilities is driven by the availability of solar radiation, underground H2 storage, and high jet fuel demand. We show that the constant supply of H2 requires an over sizing of technologies, which in turn decreases the utilisation of solar panels and electrolysers. While higher usage rates could be attained by a constant supply of electricity (e.g., via the electricity grid), the use of renewable sources is essential to guarantee a reduction in CO2 emissions compared to fossil-based jet fuel. We found that production costs in 2020 per kgfuel in Spain varied from 3.90 € (MtF) to 4.95 € (FT) using solar radiation as a sole source of energy and a point source of CO2, cutting CO2 life cycle emissions by ∼25% compared to their fossil-based counterpart (2.5–2.7 kgCO2eq per kgfuel). Potential technological improvements could reduce jet fuel production costs to 2.5–3.3 € per kgfuel for CO2 point sources while emissions could reach ∼1.0 kgCO2eq per kgfuel. Ultimately, the impact of these routes in the cost of a flight ticket would result in a minimum increase of 100–150% at present and 40–80% by 2050, accounting for current projections on technologies and carbon prices. This shows that future minimum carbon taxes of 500 € per tCO2 would be required for SAFs to become competitive.
Broader contextThe transition to establish a carbon-neutral society requires a deep transformation of energy vectors. However, the decarbonisation of the aviation sector faces limited technological options able to move away from carbon-based fuels. While the Covid-19 pandemic has caused an unprecedented reduction in demand for air travel, it is expected that the sector will reach similar pre-pandemic levels in the next 2–3 years and continue to grow thereafter. Being under an equally increasing pressure to reduce its contribution to climate change in pursue of the Paris Agreement’s targets, the sector requires efficient strategies to deploy sustainable aviation fuels. In this context, alternatives emerge which differ in resources and technological routes, with little understanding of the requirements of the transition to support a net zero sector. This lack of knowledge expands to the impact that geographical constraints impose over resources consumption and storage availability. This investigation presents a holistic assessment for the regional conversion of solar-based energy into sustainable aviation fuels, accounting for conventional and emerging processing technologies integrated within the production value chains. We compare the Fischer–Tropsch and Methanol to fuels production routes and identify the regional implications to resource consumption required to satisfy energy requirements. Our analysis presents the scale of technology deployment required, regional drivers for network deployment, impact that technological learning would represent in the future performance of solar E-fuels, and the effect over the final consumer through the cost of a flight ticket. |
At present, the aviation industry is responsible for 2–3% of global CO2 emissions, in addition to other environmental problems. According to the IATA,3 the aviation sector consumed 350 Mt of fuel in 2019, which resulted in 1.09 GtCO2. However, these emissions consider only the combustion of jet fuel and when its production and airport operations are considered, the total CO2 emissions accounted for ∼1.29 GMtCO2.4–6 The International Civil Aviation Organisation (ICAO)7 reported scenarios for the abatement of CO2 emissions of the aviation industry, including technological improvements, improved air traffic management and infrastructure use, and alternative fuels. According to Doliente et al.,8 airframe and engine manufacturers have made significant technological leaps including lighter and stronger composite materials, new innovative aircraft designs with improved aerodynamics, and incrementally more efficient engines. For example, 15 billion litres of fuel and 80 MtCO2 were saved by retrofitting wing tip devices to the wings of over 5000 existing aircraft. By using weight reduction measures on cargo containers, CO2 emissions decreased by 10 ktCO2 per year. These improvements allow greater efficiency in mileage and lower fuel consumption during travel. However, these incremental changes in an already mature engine technology, along with the long lifetime (>25 years) of existing fleets, point toward alternative fuels as a much faster and potentially more cost-effective option to reduce emissions.
Sustainable aviation fuels (SAFs) are fuels with similar chemistry to conventional jet fuel but they are produced from renewable sources, and therefore, have the potential to reduce the lifecycle emissions of the fuel. In this context, different alternatives are being considered in the short-, medium-, and long-term for the aviation industry.7,9 For instance, biofuels are already being produced and have been used in more than 150
000 commercial flights,10 with second generation technologies expected to boost their production in the coming decade.9 Another alternative relies on Power-to-Liquids (PtL), where renewable electricity is used to power electrocatalytic technologies to produce chemicals and fuels.11–13 These routes are not at a commercial scale yet but could gain traction by 2050.9 According to the ICAO,7 100% demand of jet fuel by 2050 could be met using SAFs, cutting emissions by 63%. However, the production level required could only be achieved with extremely large capital investments and substantial policy support. The cost of conventional jet fuel is highly dependent on the cost of oil, which despite cost uncertainties, results in production costs between 0.47 and 0.80 € per kgJF.3,10 In contrast, costs of aviation biofuels have been estimated to be between 0.75 and 1.75 € per kgJF.10 While these costs also depend on multiple factors, they are not expected to decrease significantly, in addition to uncertainties related to their lifecycle CO2 emissions, water and land use, and potential competition with food crops. In the PtL route, jet fuel can be produced using CO2 captured from a point source (PSC) or direct air capture (DAC) in combination with electrocatalytic H2via processes such as Fischer–Tropsch (FT) or Methanol-to-Fuels (MtF). At present, these routes present even higher costs than biofuels, with values reported to be 3.2–3.8 € per kgJF for PSC and 4.2–6.6 € per kgJF for DAC. These costs, however, are expected to decrease by almost 60% by 2050.11–13 Given the urgency to reduce the emissions of the sector, an additional alternative relies on the use of carbon offsetting. For instance, aiming to stabilise CO2 emissions at 2020 levels, the European Commission introduced the Carbon Offsetting and Reduction Scheme for International Aviation (CORSIA). In a recent analysis by Becattini et al.,13 this route results in the most cost effective alternative, with costs of 0.75 € per kgJF for PSC (60 € per tCO2) and 2.32 € per kgJF for DAC (578 € per tCO2). In addition, this route results in significantly less energy-intensive processes compared to PtL routes. However, increasing carbon taxes and social pressure to avoid fossil fuels could prevent this option from becoming a permanent solution.
While all these assessments provide valuable insights, most of them rely on general scenarios. For instance, the use of average capacity factors for electricity production or the possibility to operate technologies at a more flexible and intermittent way, even in the case of continuous processes such as FT. These assumptions result not only in economic and environmental impacts with higher uncertainties but also in potentially optimistic assessments that can neglect more realistic operating conditions, such as the need for storage of intermediate products. In this context, supply chain models present a viable option to reduce such uncertainties by jointly modelling spatio-temporal representations, availability of resources, technologies selection, and network design.14,15 Aiming to build on these approaches and reduce uncertainties during the assessment of SAFs, we propose the use of a bottom-up supply chain model applied to the production of jet fuel from solar energy. Defined as a Resource-Technology Network (RTN), the model accounts for the availability of resources in a given region across multiple periods, to then deploy the most suitable technologies for the production of jet fuel, where we include the FT and MtF routes. The technologies included rely on process modelling and optimisation that can help to identify synergies between them, and therefore, generate highly-integrated and energy-efficient production routes. Ultimately, the model provides a network with minimal cost and environmental impact, as monetary factors are introduced in the form of a carbon tax. The RTN model is applied to Spain, which is a region with high potential to deploy solar energy and has air traffic with over two million operations per year.14,16
This work is organised as follows. We first present the definition of the spatio-temporal representation defined in the case study. We then move to the RTN model, defining the resources and technologies considered in the superstructure. We also present the mathematical formulation of the model and the assumptions behind the accounting of lifecycle CO2 emissions. In Section 4, we discuss the results of the network for the current status of the technologies while Section 5 includes multiple sensitivity analyses where a performance forecast is also discussed. In Section 6, we report a comparison of our results with other SAFs and the implications in the cost of a flight ticket to finally present the conclusions of our analysis.
430 bpd (6.47 Mt per year) of jet fuel, transported more than 275 million people, and had roughly two million arrivals and departures.16–18 While the model was forced to satisfy the full demand of jet fuel in all the scenarios, a minimum demand was defined for the regions located in the mainland. This minimum demand was defined by those airports whose operations where higher than 1% of the total of operations or transported more than 1 million passengers.16 An additional consideration is that of the Canary and Balearic Islands, as they are not part of Spain's mainland. In the case of the Balearic Islands, the region accounts for 16% of the total operations and 15% of the traffic of passengers. Here, the demand for jet fuel is added to the region of Barcelona without accounting for further transportation to the islands. In the case of the Canary Islands, approximately 20% of the total operations took place across its eight airports, which also accounted for 17% of the total traffic of passengers. Here, we assume that the demand for jet fuel has to be fulfilled by the network in the mainland, although their specific contribution is not fixed to any particular province. That is, their demand is not accounted for to define the minimum regional demand to be satisfied. Under these assumptions, 23 out of the 48 active airports in Spain are used to define the minimum regional demand of jet fuel shown in Fig. 1, which accounts for 78% of the total demand. The list of airports included is reported in the ESI.†
| Technology | Radiation | Elec (MW) | Heat (MW) | CO2 (kg) | CO (kg) | H2 (kg) | MeOH (kg) | H2O (kg) | C3H6 (kg) | Jet fuel (kg) | Gasoline (kg) |
|---|---|---|---|---|---|---|---|---|---|---|---|
| BH | 1 | −30.3 | |||||||||
| CSP | −1 | 1 | |||||||||
| PV | −1 | 1 | |||||||||
| AWE | −0.060 | 1 | −10.11 | ||||||||
| SOEC | −0.064 | −0.014 | 1 | −9.01 | |||||||
| SHIFT | −1.2 × 10−3 | −1.58 | 1 | −0.072 | 0.645 | ||||||
| SOEC CO2 | −3.4 × 10−4 | −4.0 × 10−4 | −1.571 | 1 | |||||||
| SOEC CO-ele | −0.0102 | −1.5 × 10−3 | −1.571 | 1 | 0.1429 | −1.286 | |||||
| ME CO2 | −1.6 × 10−5 | 1.1 × 10−3 | −1.509 | −0.2032 | 1 | 0.5789 | |||||
| ME CO | 1.2 × 10−4 | 1.2 × 10−3 | −0.085 | −0.866 | −0.1278 | 1 | 0.001 | ||||
| ME CO/CO2 | −2.0 × 10−5 | 5.8 × 10−4 | −0.264 | −0.708 | −0.137 | 1 | 0.089 | ||||
| FT | −1.4 × 10−4 | 0.807 | −3.282 | −0.408 | 1 | 0.3038 | |||||
| MTP | 7.4 × 10−6 | 1.1 × 10−4 | −2.345 | 1 | |||||||
| PTF | 1.6 × 10−4 | −2.07 | 1 | 1.057 |
| Technology | CAPEX (€M) | OPEX (€M) | CO2 (tCO2 per unit) | ||
|---|---|---|---|---|---|
| s 1 | s 2 | s 3 | |||
| BH (MW h) | 0.249 | — | — | 9.5 × 10−7 | — |
| PV (MW h) | 0.810 | — | — | 7.9 × 10−7 | 0.062 |
| CSP (MW h) | 5.766 | — | — | 5.3 × 10−6 | 0.043 |
| AWE (kg) | 5.9 × 10−2 | — | — | 4.7 × 10−8 | — |
| SOEC (kg) | 2.4 × 10−1 | — | — | 1.3 × 10−7 | — |
| SHIFT (kg) | 2.5 × 10−3 | — | — | 2.1 × 10−9 | — |
| SOEC CO2 (kg) | 3.0 × 10−2 | — | — | 2.7 × 10−8 | — |
| SOEC CO-ele (kg) | 3.36 | — | — | 3.0 × 10−6 | — |
| ME CO2 (kg) | 4.2 × 10−3 | 3.2 × 10−3 | 2.7 × 10−3 | 2.2 × 10−8 | 5.21 × 10−5 |
| ME CO (kg) | 1.0 × 10−3 | 7.9 × 10−4 | 6.7 × 10−4 | 5.3 × 10−9 | 1.33 × 10−4 |
| ME CO/CO2 (kg) | 1.8 × 10−3 | 1.4 × 10−3 | 1.2 × 10−3 | 9.1 × 10−9 | 1.22 × 10−4 |
| FT (kg) | 1.3 × 10−2 | 1.1 × 10−2 | 7.4 × 10−3 | 7.8 × 10−8 | 1.31 × 10−4 |
| MTP (kg) | 3.2 × 10−3 | 2.1 × 10−3 | 1.3 × 10−3 | 1.8 × 10−8 | 7.92 × 10−5 |
| PTF (kg) | 1.6 × 10−3 | 1.0 × 10−3 | 6.6 × 10−4 | 1.4 × 10−8 | 2.46 × 10−5 |
| 2H2O → 2H2 + O2 | (R1) |
| CO2 + H2 ↔ H2O + CO | (R2) |
:
CO2 of 3. If pure CO is desired, the products of the SHIFT reaction should undergo further treatment. In this study, this analysis is disregarded and the output of the SHIFT reaction is directly fed into the downstream processes.
![]() | (R3) |
The reactor had a cell potential difference of 1.5 V and current density of −1 A cm−2. After the reaction, a CO/CO2 separation unit is included based on cryogenic liquefaction.
| nCO2 + mH2O → nCO + mH2 + (m + n)/2O2 | (R4) |
| CO + 2H2 ↔ CH3OH | (R5) |
| CO2 + 3H2 ↔ CH3OH + H2O | (R6) |
Whether the feed to the process is CO2, CO, or CO2/CO, the production process is identical, which was modelled in Aspen HYSYS (Fig. 3a).33 The reaction is exothermic and the heat surplus is coupled with a Rankine cycle to cogenerate electricity. The output of the reactor is then separated in a series of flash tanks, where the gases are recycled to the reactor while the liquids are sent to a distillation column. Here, water and methanol are separated, obtaining methanol with a purity >99.5%. Temperatures and pressures of the reactor and distillation column were optimised for each feedstock based on their total annualised cost (TAC).26 While CO2 and CO are assumed pure in MEOH–CO2 and MEOH–CO, respectively, the blend CO/CO2 assumes 75/25 wt% in MEOH–CO/CO2. The three production scales considered are: 50 tMEOH per h, 100 tMEOH per h, and 150 tMEOH per h.
:
1. The process was modelled in Aspen Plus v9 using the Predictive Soave–Redlich–Kwong equation of state. The FT reactor and hydrocracker follow the models reported by Graciano et al.40 while the remaining units were modelled using equilibrium reactors. Costs for these units were based on inlet mass flowrate.24 The off-gas stream is burned and the heat used to satisfy the demand of the process while the heat released by the Fischer–Tropsch reactor was coupled with a Rankine cycle.39 Three scales were considered for the production of jet fuel: 50 tJF per h, 150 tJF per h, and 300 tJF per h. A unit for carbon capture using MEA was also included in the model to sequestrate the CO2 emissions generated from the combustion of the purge stream.41
![]() | (1) |
| NTj,i,l = NTj,i,l−1 + INVTj,i,l ∀j ∈ JUS, i, l | (2) |
| NTj,i,l,sS = NTj,i,l−1,sS + INVTSj,i,l,s ∀j ∈ JS, i, l, s | (3) |
The installed capacity of each technology is limited by a given lower/upper bound of each scale level in each cell:
| LTj,sSXi,j,l,s ≤ INVTSj,i,l,s ≤ U(j, s)TSX(i, j, l, s) ∀i ∈ JS, i, l, s | (4) |
For each cell i, any technology j at each investment time period l, only one scale can be selected:
![]() | (5) |
The production rate P of any technology j in each cell i is limited by the capacity and capacity factor of the available technology units:
![]() | (6) |
| Pj,i,t,k,l ≤ NTj,i,lCFj,t,k ∀j ∈ JUS, i, t, k, l | (7) |
| NSr,i,l = NSr,i,l−1 + INVSr,i,l ∀r ∈ RS, i, l | (8) |
The amount of the storage for any resource r at any time period should be limited by the installed capacity of the storage:
| RSr,i,t,k,l ≤ NSr,i,l ∀r ∈ RS, i, t, k, l | (9) |
r,i,i′,t,k,l,tr. This variable is limited by a user-specified parameter Qmaxr,tr. A binary variable Yr,i,i′,l,tr = 1 indicates that the transportation method tr is allowed to transport resource r between cells i and i′ whereas Yr,i,i′,l,tr = 0 indicates that transport is not allowed.![]() | (10) |
![]() | (11) |
For each cell, its specific minimum demand requirement should also be met:
| Dr,i,t,k,l ≥ Dminr,i,t,k,l ∀r ∈ RP, i, t, k, l | (12) |
![]() | (13) |
![]() | (14) |
The weighting factor for OBJWTCapEx,l is assumed to be 0.117, which is equal to the capital recovery factor for 20 years with a 10% interest rate. The OBJWTOpEx,l takes a value of 1 based on an annual operation, while the weighting factor for the CO2 emissions OBJWTCO2,l is based on a carbon tax with a value of 54 € per tCO2.50
In terms of hydrogen, both routes select AWE electrolysis and the corresponding storage to guarantee its supply downstream, as FT and MtF operate continuously. Following PV, the installed capacities for the hydrogen system are defined by the winter season, resulting in maximum production rates of 1082 and 1313 tH2 per h in FT and MtF, respectively. During this period, ∼50% of H2 is sent to the JF production trains while the remaining 50% goes to storage, resulting in an annual capacity factor of 51% for AWE. While more H2 is required in the MtF route, the net requirement per kgfuel is lower than the FT route, consuming 0.44 and 0.57 kgH2 per kgfuel in MtF and FT, respectively. This larger consumption of H2 in FT is caused by the heating requirements of the process (supplied by H2 in the NE scenarios) and the production of butene as a byproduct in the process. When electricity from the grid can be imported, the installed capacity of AWE decreases by 33%, allowing it to operate at full capacity during the night period when cheap electricity from the grid is available, increasing its annual capacity factor to 70%.
The production of jet fuel is given by the corresponding route. In the FT route, CO2 is consumed at a maximum rate of 3337 t h−1, being fed to the CO production technologies SHIFT and SOEC CO2. When both technologies operate, SHIFT consumes 3615 tCO2 per h while SOEC CO2 consumes 360 tCO2 per h. The remaining 638 tCO2 per h still required by the network are supplied by the CO2 captured after the combustion of the flue gas in the FT process. The production of jet fuel in MtF includes ME CO2 and ME CO/CO2 to produce MeOH. Here, the network identifies energy synergies between these routes, resulting in installed capacities of 606 and 3116 tMEOH per h for ME CO2 and ME CO/CO2, respectively. This route consumes 1737 tCO2 per h directly in the production of MeOH while the remaining 3467 tCO2 per h is used in the production of CO via SHIFT (3151 tCO2 per h) and SOEC CO2 (315 tCO2 per h). While the installed capacity of SOEC CO2 is 10% of the total CO production technologies, its annual contribution is only 4%. The reason being that SOEC CO2 operates during summer and mid-season, when it benefits from ‘free’ electricity available from the PV system, which does not operate at full capacity during these periods.
743 M€, releasing 22.7 MtCO2eq, and producing 6.47 MtJF and 1.966 Mtgas. These costs represent 4.95 € per kgfuel with life cycle emissions of 2.69 kgCO2eq per kgfuel. From Fig. 7, capital costs represent 95% of the total cost with operating costs represent the remaining 5%. Among the capital costs, PV, AWE, and electricity storage are the main contributors, representing 50%, 26%, and 14%, respectively. Among the operating costs, 3% come from the fixed costs of operation while 2% from CO2, and less than 1% from water and transport of H2 and jet fuel. The 2.69 kgCO2eq per kgfuel of this scenario represent a reduction by 25% of current CO2 emissions embedded in the life cycle of the liquid fuels (3.60 kgCO2eq per kgJF). Under the assumptions used in the model, PV contributed with 2.12 kgCO2eq per kgfuel while the CO2eq embedded in the capture of imported CO2 resulted in 0.40 kgCO2eq per kgfuel. In terms of cost, this scenario is 7.5-fold more expensive than the oil-based jet fuel with carbon tax (0.66 € per kg), resulting in a cost of CO2 avoided of 4700 € per tCO2.
956 M€, releasing 32.4 MtCO2eq and producing 6.47 MtJF and 6.837 Mtgas. This represents an investment 24% higher than the FT process but producing fuels 23% cheaper on a mass basis. The lower cost per kgfuel follows the higher conversion efficiency observed in the MtF route compared to the FT process. However, this process also generates a larger amount of gasoline, following a ratio of 1
:
1. The breakdown of costs presents a similar behaviour to FT, where capital costs represent 94% of the total cost, and operating costs represent the remaining 6%. Similarly, PV, AWE, and electricity storage are the main contributors to the cost, representing 56%, 17%, and 14%, respectively. In terms of transport, the network requires the installation of pipelines and trucks to supply jet fuel and intermediate resources between most regions, accounting for 3% of the costs. Among the operating costs, an additional 3% comes from the technologies while 2% is attributed to CO2. This alternative releases 2.44 kgCO2eq per kgfuel, representing a reduction by 10% compared to the FT route and 32% compared to current production processes. In terms of cost, this scenario results in production costs of 3.91 € per kgfuel, being six-fold more expensive than the oil-based jet fuel including the carbon tax, with a cost of CO2 avoided of 2800 € per tCO2.
At present, the use of electricity from the grid would result in fuel costs of 2.5–2.8 € per kgfuel, with the carbon tax representing 20% of the cost. In these scenarios, CO2 emissions would reach values from 7.2–8.2 kgCO2 per kgfuel, twice the impact of current fossil-based options. An analysis over the import of electricity from the mix without exceeding current CO2 emissions is presented in the ESI.†
In terms of electricity demand, the deployment of these technologies would require 298 and 361 TW h in the FT and MtF routes, respectively. In both cases, the electricity required surpasses the 258 TW h of electricity consumed in Spain during 2020.56 The cost of electricity generated from solar PV is 80 € per MW per h without accounting for storage and 100 € per MW per h when electricity storage is included. The capacity factor of PV across the year was 13.6%. When PV is used at its maximum capacity (scenario EI), the capacity factor of PV increases to 18%, resulting in electricity production costs of 60 € per MW per h. Here, the inclusion of a carbon tax shows a reduction in the amount of electricity being imported, resulting in a fuel that has significantly more life cycle emissions than conventional routes (8.18 kgCO2eq per kgfuel in FT and 7.17 kgCO2eq per kgfuel in MtF). Electricity storage is one of the main cost drivers required to guarantee the operation of AWE during the night period (minimum load capacity of 30%). Given the high cost associated to this technology starting at 225 € per kW, the network seeks to minimise its deployment. For reference, the London Gateway battery project reports an investment of 380 M€ for a 320 MW/640 MW h.57 The results reported in the network would require the deployment of 400 systems of the same size. This deployment could be reduced by implementing a combination of technologies, such as wind or nuclear. When importing electricity from the grid, the model avoids the need for electricity storage and reduces the deployment of PV to a third.
A total of 5 MtH2 in FT and 6 MtH2 in MtF would be required to supply the demand of H2, representing around 8% of current global H2 production. The production cost of H2 in the network was 7.6 € per kgH2 with embedded CO2 emissions of 3.72 kgCO2eq per kgH2 and an average use of the electrolysers of 50.9%. When electricity import from the grid was allowed, the production cost was reduced to 3.70 € per kgH2 releasing 14 kgCO2eq per kgH2. These values are higher than H2 from steam methane reforming (SMR), which reports costs in the order of 2 € per kgH2 and emissions of 9–12 kgCO2eq per kgH2 (4.5–5.8 kgCO2eq per kgH2 with CCS).58 Furthermore, autothermal reforming of natural gas (ATR) attains lower CO2 emission rates with values of 9.8–10.9 kgCO2eq per kgH2 without CCS and 2.5–3.4 kgCO2eq per kgH2 with CCS.58 Therefore, the production of H2 importing electricity from the grid reports no benefits neither economically nor environmentally.
SOEC CO2 is selected to operate during summer and mid-season, when it can consume the excess of electricity generated by PV. Under these conditions, the production cost of CO is ∼0.40 € per kgCO from SOEC CO2 compared to ∼0.46 € per kgCO from SHIFT. The use of H2 in the SHIFT process represents an indirect consumption of 4.32 kW h per kgCO, which is 27% more than that required by SOEC CO2 (3.40 kW h per kgCO). While the capital costs of SOEC CO2 still present this technology as expensive, capital costs below 17
000 € per kgCO could make it more attractive to deploy than SHIFT.
Overall, the MtF route presents a slightly better performance against its FT counterpart in both cost and CO2 emissions per kgfuel. However, its annual investment is approximately 25% larger than the FT route given its higher yield toward gasoline. In addition, the limits currently imposed in the model for the deployment of technologies create the need for a vast number of plants and a more elaborate transport network to supply the demand of jet fuel. This could result in an advantage if the demand of products changes across time, as methanol and propylene are available at multiple points in the network. When compared to the oil-based jet fuel, both routes represent increases by 10-fold in FT and 8-fold in MtF, with costs of CO2 avoided of 4700 and 2800 € per kgCO2, respectively. The costs reported for the NE scenarios are higher than those reported in the literature, with values between 3.2–3.8 € per kgfuel for the FT route and a point source of CO2.11–13 In addition to the differences in costs and efficiencies used for each technology, one of the main reasons for such contrasts is the constant need of hydrogen to supply the jet fuel production technologies. In addition, the availability of electricity relies on the solar profiles of the region across the year, which results in reduced capacity factors, and therefore, the need to over-size the network. The whole capacity required is dictated by the availability of solar radiation during the winter season, when the highest use of the panels is observed during the midday period at rates of ∼41%.
![]() | ||
| Fig. 8 Jet fuel production cost for FT and MtF at different import costs of CO2. NE: no energy import to the network; EI: energy import allowed (natural gas and electricity from the grid). | ||
Fig. 9 shows the results for the scenarios described for MtF. Results for FT follow a similar pattern and are reported in the ESI.† In both routes, the cost of H2 storage has a minimal impact over the production cost of the fuel. When salt caverns are made available (100–400 € per kg), the network makes use of this technology, mainly using those located in the region of Valencia. As the costs of storage are raised to 1200 € per kgH2, meaning that compression of hydrogen is available in all the country, the model shows a more distributed arrangement at similar costs.
![]() | ||
| Fig. 9 MtF fuel production costs and installed capacities of PV, CSP, AWE, storage of electricity and hydrogen for different storage costs. | ||
Electricity storage is required to guarantee the operation of all technologies during the night period. At the costs reported in Table 3, electricity production in the network for scenarios NE was 100 € per MW per h in PV and 170 € per MW per h in CSP, resulting in the deployment of PV. At costs of 500 € per kW for electricity storage the model starts to deploy an arrangement PV-Storage-CSP. Beyond costs of 800 € per kW for electricity storage, PV-CSP becomes the cheapest alternative, being deployed up to the level at which electricity storage is not required. In this scenario, electricity generation from CSP is 43% in FT and 46% in MtF. This also reduces the installed capacities of PV, AWE, and H2 storage, with an increase in fuel costs by 18% in both routes. The capacity factor of CSP is assumed at 0.45,52 with values up to 0.6 reported along with minimum loads of AWE of 10%. These technological improvements could further reduce production costs. While the use of other electrolysis technologies could also reduce the need for electricity storage, the current prices of these routes are still higher than the system of PV-AWE-Storage.30
27,54,61 A scenario for 2015 is included to observe the improvements attained by these technologies over recent years.
Fig. 10 shows the fuel cost and CO2 emissions for a system PV-Storage. A scenario based on PV-CSP is also reported in the ESI.† The costs reported include different costs of CO2, aiming to present production costs employing different sources, particularly DAC. As observed, a reduction in capital costs beyond 50% can be expected by 2050 compared to 2015, reaching minimum values of 2.50 € per kgfuel and life cycle emissions in the order of 1.0 kgCO2eq per kgfuel. These reductions are in agreement with values reported in the literature.11–13 However, our total costs are still higher than those reported given the need of a constant supply of H2. The minimum costs projected by 2050 consider CO2 prices around 25 € per tfuel. However, at this time it would also be expected that DAC would represent a primary source of CO2, as other point sources reduce their direct emissions. Using CO2 sources in the order of 500 € per ton by 2050 would result in similar production costs as being produced in 2020 with a different (and cheaper) point source of CO2. This shows that prices below 4.0 € per kgfuel will be difficult to attain in Spain as it seeks to develop a cleaner path toward aviation fuel. In terms of CO2 emissions, we can observe a significant reduction from 2.6–2.9 kgCO2eq per kgfuel for PV and 2.3–2.6 kgCO2eq per kgfuel for CSP in 2015 to 1.0 kgCO2eq per kgfuel for both PV and CSP by 2050. This is the result of a decarbonised energy mix used in the manufacture of the corresponding technologies.
Fig. 11 shows the economic breakdown for MtF. The results for FT follow the same trend and are reported in the ESI.† On average, the network reduced the deployment of electricity storage by 80 GW in FT and 100 GW in MtF for each 10% reduction of AWE minimum load. Similarly, an increase in AWE by 200 tH2 per h and 1100 kg of H2 storage was observed. As a result, changes in the electrolyser operation reflected a minimum impact for the total production costs of the fuels in 2015 and 2020. The further reduction costs defined for PV and AWE in 2030 and 2050 showed potential cost reductions up to 15% if electricity storage remains at 225 € per kW. The increase in cost of H2 storage from 100 to 1200 € per kgH2 represented an additional 0.1 € per kgfuel in FT and MtF. Average capacity factors for AWE were 54%, 46%, 39%, and 33% for minimum loads of 30%, 20%, 10%, and 0%, respectively. The production costs of hydrogen in the supply chain were between 11.3–11.5 € per tH2 in 2015, 7.5–8.0 € per tH2 in 2020, 6.5–7.0 € per tH2 in 2030, and 3.5–4.5 € per tH2 in 2050.
Efuel costs reported show a variation between 1.7–6.2 € per kgfuel in 2020 and 0.8–2.5 € per kgfuel in 2050 for a point source of CO2 (PSC-25 € per tCO2). Here, the lower capacity factors for PV result in higher production costs compared to wind-based electricity. A detailed analysis of the potential for hybrid power (wind and solar power) combined with energy storage technology to reduce costs is beyond the scope of this work. In our assessment, the costs of solar E-fuels in Spain result in 4–5 € per kgfuel using a PSC (25 € per t) and 7–8 € per kgfuel using DAC for 2020, sitting in the upper half of the values reported in the literature. By 2050, fuel production in Spain varies from 2.5–3.3 € per kgfuel for PSC and 4.2–5.0 € per kgfuel for DAC. Here, our projections are above those calculated from the literature. The reason being the need to oversize PV, AWE, and their corresponding storage in order to guarantee a constant supply of hydrogen. These costs could be reduced if intermittent or a more flexible operation becomes possible for processes like FT or MtF.63 Similarly, guaranteeing the supply of electricity to the system could reduce costs. However, this supply should rely on renewable sources, given that import from the electricity mix in Spain would result in more polluting fuels than BAU. In this context, Fig. 12 also shows the fuel life cycle CO2 emissions of the alternatives proposed (right axis). Here, a significant reduction is observed when using E-fuels to around 1.0 kgCO2 per kgfuel by 2050. At this point, the CO2 embedded in the manufacture of solar panels would represent jet fuel with similar emissions to those of biofuels. Similarly, by 2050 the emissions embedded in PV are expected to have similar values to wind electricity. From the alternatives presented in Fig. 12, only offsetting would result in net-zero fuels. Using BECCS for this purpose, and assuming costs in the range of 15 and 250 € per tCO2, the cost of jet fuel would result in values between 0.6–1.5 € per kgfuel (BAU + BECCS). In the case of DAC, the costs of the fuel would represent 2.7–4.2 € per kgfuel (BAU + DAC). These values are in agreement with those reported by Becattini et al.13
Fig. 13 shows the total cost of a flight ticket per available seat km, which refers to the cost that a passenger pays per km travelled for the aircraft considered. According to the previous results, the values for FT/MtF refer to production costs in Spain. According to the data assumed for 2020 and with a cost of 25 € per tCO2, the flight ticket would increase by 127% in the FT route and 98% in MtF. If we consider a cost of 500 € per tCO2, the flight ticket would increase by 173% in FT and 142% in MtF, reaching costs of 0.22 € and 0.19, respectively. By 2050, the costs would present a reduction up to 0.18 € per seat km in FT and 0.14 € per seat km in MtF. This would represent increases by 80% in FT 40% in MtF compared to BAU, which would reach values around 0.10 € per seat km when a the carbon tax of 190 € per tCO2 defined by the IEA is included.55 This shows that carbon prices >500 € per tCO2 in 2050 would be required to make solar efuels economically attractive compared to BAU.
![]() | ||
| Fig. 13 Total cost of flight ticket per available seat km. Costs represent a basic-economy ticket in a competitive route for a flight of 1700 km. | ||
000 M€ in FT and 52
000 M€ in MtF would be required to fulfill the current demand for jet fuel in Spain exclusively based on solar radiation, attaining life cycle CO2 reductions of 25%. These costs translate into fuels eight to ten times more expensive than the current oil-based scenario, representing costs of CO2 avoided of 4700 in FT and 2800 € per kgfuel in MtF. Given that the main costs drivers are PV, alkaline water electrolysis, and electricity storage, the import of electricity from the grid would reduce investment costs by ∼50%. However, this would come at the expense of increased emissions that surpass even those of conventional routes even when a carbon tax is imposed, reaching values of 7.2–8.2 kgCO2eq per kgfuel. The infrastructure requirements to meet Spains annual jet fuel demand are substantial. The deployment of PV would have to supply 15–40% more electricity than the total of 258 TW h consumed in Spain in 2017. Similarly, 5–6 MtH2 would be required, representing round 8% of current global H2 production. Electricity storage, another key element of the network, also shows a vast deployment, with capacities 400 times that of the London Gateway battery-storage system currently being developed. At storage costs around 500 € per kW, a deployment of CSP was observed, becoming the preferred choice over storage at costs above 800 € per kW. Further technological improvements could result in efuel costs as low as 2.2 € per kgfuel by 2050. However, by that time, the energy system may have significantly decarbonised, rendering DAC the main source of CO2. This would result in fuel production costs around 4.5 € per kgfuel, which are similar to the values estimated for 2020 using a PSC. In other regions, these values may be further reduced due to more favourable renewable resources.
Allowing the import of electricity in the network, up to the level in which the same emissions as the BAU option are attained, presents cost savings by 34% in 2020. A cleaner electricity mix than Spain could allow for further reductions. In both routes, increased rates of electricity are imported over time, reducing the cost of the fuel until the constraint on CO2 emissions is reached by the system. By 2050, the technological improvements and cost reductions of PV and AWE allow further cost and CO2 reductions. Ultimately, the impact of these process routes in the cost of a flight ticket in Spain would cause increase by 100–150% at present (2020) and 40–80% by 2050. These contributions could be considered as representative for an economy class, 1000 mile flight of a competitive flying route. As other factors come into play, such as business class, shorter flights, taxes, or less competitive routes, the fuel contribution to the cost of the flight ticket would be reduced.
The environmental benefits of deploying these process routes are evident, reducing life cycle emissions by ∼25% at present and expected reductions by 75% in 2050. From the behaviour observed, electricity storage is an element that is minimised under every scenario, and further integration of technologies able to reduce its deployment should be considered. A potential alternative is the coupling of solar PV with other electricity sources, such as wind, hydro, or nuclear. This could potentially reduce the amount of storage required to operate the electrolysers during the night period, resulting also in increased capacity factors and lower capital costs. Another alternative could be the use of electrolysers which are more easily able to operate intermittently, such as PEM or SOEC. The problem, however, is that the capital costs associatedwith these technologies are still higher than alkaline water electrilysis including for electricity storage. Overall, the costs associated with these routes should be carefully examined and compared against other alternatives, such as biomass gasification, pyrolysis, or carbon offsetting. Such a comparison would complement this analysis and further advance the understanding of different pathways towards net zero aviation fuel.
r,i′,i,t,k,l,tr
| Flow rate of resource r from cell i to i′ at time period t, k, l with transportation mode tr |
| CFj,t,k | Capacity factor of technology j at time period t in major time period k |
| i, i′ ∈ IMP | Spatial cells that can import |
| i, i′ | Spatial cells |
| r | Resources |
| r ∈ RD | Resources which need network design |
| r ∈ RI | Resources that can be imported |
| r ∈ RS | Resources which can be stored |
| r ∈ RF | Resources which can be transported |
| r | Resources |
| j | Technologies |
| j ∈ JS | Scalable technologies |
| j ∈ JUS | Non-scalable technologies |
| t | Daily time period |
| k | Seasonal time period |
| l | Investment period |
| m | Metric: CapEx, OpEx, CO2 emissions |
| tr | Transportation mode: truck, pipe |
| s | Capacity scale range of scalable technology |
| D min r,i,t,k,l | Minimum demand of r in cell i at time period t, major time period k and investment time period l (kg h−1) |
| Disti,i′ | Distance from cell i to cell i′ (km) |
| L TS j,s | Lower installed capacity bound for technology j within scale |
| μ j,r | Rate of r production/consumption per unit in technology j (kg or MW) |
| OBJWTm,l | Weight of metric m in investment period l |
| PIt | Hours assigned to each daily period t (hour) |
| PMk | Number of the seasonal period k (e.g. sample day of a season) |
| Q max r,tr | Maximum flow rate of resource r in transport mode tr (kg h−1) |
| Targetr,l | Target of final product resource r (e.g. jet fuel) (ton) |
| U TS j,s | Upper installed capacity bound for technology j within scale s |
| VIJj,i,m | Technology j metric m investment coefficient (M/unit capacity) |
| VISr,i,m | Storage technology for material r in cell i metric m investment coefficient |
| VPJj,m | Technology j metric m process coefficient |
| VTr,m | Flow value of r/m with truck transport |
| VIr,m | Import value of r/m |
| VYr,m | Value per metre of network of r/m |
| D r,i,t,k,l | Demand of r in cell i at time period t, major time period k and investment time period l (kg h−1) |
| IMr,i,t,k | Import of resource r in cell i period t major period k (MW h or kg h−1) |
| INVSr,i,l | Installed capacity of storage for material r in cell i at investment period l |
| INVTSj,i,l,s | Installed capacity of scalable technology j in cell i at investment period l at scale s |
| INVTj,i,l | Installed capacity of non scalable technology j in cell i at investment period l |
| N S r,i,l | Capacity of storage for material r in cell i at investment period l |
| N TS j,i,l,s | Capacity of scalable technology j in cell i at investment period l at scale s |
| N T j,i,l | Capacity of non scalable technology j in cell i at investment period l |
| P j,i,t,k,l | Production rate of technology j in cell i at periods t, k, l (MW or kg h−1) |
| RSr,i,t,k,l | Amount of resource r stored in cell i period t major period k at investment time period l (MW h or kg) |
| VMm,l | Total value of metric m in investment time period l |
| X i,j,l,s | Binary variable, 1 if there is installed technology j in cell i at investment period l within the scale level s, 0, otherwise |
| Y r,i,i′,l,tr | Binary variable, 1 if resource r between cell i and i′ can be transported via transportation method tr, 0, otherwise |
| AC | Objective function: annualised cost |
Footnote |
| † Electronic supplementary information (ESI) available: Details and results of the production of jet fuel from solar energy. See DOI: https://doi.org/10.1039/d1ee03437e |
| This journal is © The Royal Society of Chemistry 2022 |