Open Access Article
Lanshu Xu
,
Yue Li
,
Mengying Jia,
Qiang Zhao,
Xiaojuan Jin* and
Chunli Yao*
MOE Engineering Research Center of Forestry Biomass Materials and Bioenergy, Beijing Key Laboratory of Lignocellulosic Chemistry, Beijing Forestry University, Beijing 100083, China. E-mail: jxj0322@bjfu.edu.cn; chunliyao2006@163.com; Tel: +86-010-62337178
First published on 21st September 2017
Free-standing, binder-free and flexible activated carbon/reduced graphene oxide (AC/rGO) composite films with various ratios were fabricated via a facile vacuum-filtration process. It was proved that two-dimensional rGO sheets were an ideal adhesive support for AC. The optimal ratio (AC
:
rGO = 2
:
1) was determined and the film electrodes displayed a high area specific capacitance of 486 mF cm−2 with a mass of 2.35 mg cm−2 (specific capacitance of 207 F g−1) at 0.2 mA cm−2. The assembled supercapacitor had the advantages of being flexible, lightweight, cheap and environmentally friendly, and can achieve a superior energy density of 16.2 μW h cm−2 at a power density of 100 μW cm−2 and 85% capacitance retention after 10
000 charging/discharging cycles. Moreover, 90% of the capacitance was retained after 1000 bending cycles and there was almost no performance change under different bending angles. These results well demonstrated a great potential for application of AC/rGO film electrodes in wearable and portable electronics.
Based on the charge storage mechanism, pseudocapacitive materials such as conductive polymers, as well as metal oxides and hydroxides, metal nitride and metal carbide can deliver higher capacitance via redox reaction.6–8 Relatively speaking, carbon materials such as activated carbon (AC), carbon nanotubes, carbon fibers or graphene, are derived from natural resources and have been regarded as ideal substitutes of metal materials,9,10 which present good rate capability and excellent cycling stability via reversible ion adsorption/desorption.11–13 Especially for graphene with two-dimensional honeycomb structure, high surface area and high carrier mobility, possesses excellent mechanical flexibility and good electrical conductivity.14 However, its compact lamellar structure and the easily caused agglomeration reduce the efficiency of specific surface area and affect the infiltration of electrolyte, which result in the graphite cannot suitable for supercapacitors. So far, various methods have been used for the graphene-based composites to solve this problem, such as hydrothermal method,15,16 chemical vapour deposition (CVD),5 electrophoretic deposition,17 spin coating18 and layer-by-layer self-assembling.19 The transition metal oxides and hydroxides,20–22 conducting polymers,23–25 and biomass materials26,27 were composited with graphene-based materials and widely developed in flexible electrode materials. However, carbon–carbon composites have rarely been reported.
ACs as the earliest and the most widely application of electrode materials, are hardly ever reported in flexible supercapacitor. AC materials are generally abundant, renewable, environmental friendliness and relatively low price,28 which mainly come from the timber, nut hull, coconut shell, walnut shell, jujube shell, apricot shell, etc. Moreover, AC electrode has prominent properties such as easy process ability, higher pore content, larger specific surface area, and higher electrochemical stability.29 However, the powder-like AC is difficult to handle as flexible electrode materials, binders (poly(vinylidene fluoride) (PVDF)) or (poly(tetrafluoroethylene) (PTFE)) are always needed in composites.30–32 Therefore, it may be a good decision to choose ACs as intermediates, and graphene as an ideal binder and supporter for flexible supercapacitor electrode materials.
Herein, we reported a novel activated carbon/reduced graphene oxide (AC/rGO) film as the electrode material of flexible supercapacitor, in which ACs, derived from waste fiberboard, were assembled with graphene obtained by chemically reduced graphene oxide. For the first time, free-standing, binder-free, flexible and lightweight AC/rGO film electrodes were obtained by vacuum filtration method. Three-dimensional porous AC/rGO film electrodes could achieve a significant synergistic effect. The morphology structures as well as electrochemical performances of different ratios of AC/rGO film electrodes were discussed and the optimum proportion was explored. As expected, the flexible supercapacitor possessed excellent mechanical property and remarkable electrochemical performances.
:
3 and further activated at the temperature of 750 °C for 60 min in oven. Finally, the activated ACs were washed and filtered using deionized water and 1 M HCl solution respectively until to neutral pH, and dried at 105 °C for 8 h, then stored for subsequent use.17,32
:
1 were mixed and dispersed in N,N-dimethylformamide (DMF) to produce a homogeneous dispersion. The preparation procedure of AC/rGO composite films was depicted in Fig. 1. Based on the premise of ensuring the formation of flexible film, 5 mL of GO aqueous dispersion was mixed with 40, 20, 10 and 6.7 mL of AC (0.5 mg mL−1) dispersion respectively, corresponding to add 5, 25, 35 and 38.3 mL of DMF in Erlenmeyer flask to ensure that the volume ratio of deionized water to DMF was 1
:
9, which was advantageous to improve the dispersion of GO.35 Then the Erlenmeyer flasks were sealed with preservative film and under ultrasonic vibration for 2 h. Subsequently, a small quantity of hydrazine hydrate (80%) was added in the resulting homogeneous dispersion to chemically reduce GO. The weight ratio of hydrazine hydrate to GO was about 7
:
10.36 After being vigorously shaken or stirred for 5 min, the Erlenmeyer flasks were put in a water bath (∼95 °C) for 3 h. Finally, the mixture solution was vacuum-filtrated using an organic microporous membrane (50 mm in diameter, 0.45 μm in pore size). For comparison, the pure rGO solution was treated in the same procedure, and the obtained films were marked as AC
:
rGO = 2
:
1, AC
:
rGO = 1
:
1, AC
:
rGO = 1
:
2, AC
:
rGO = 1
:
3, rGO, respectively.
:
rGO = 2
:
1 (1 cm × 3 cm) film electrodes and polypropylene membrane were immersed in the hot H2SO4/Polyvinyl alcohol (PVA) gel electrolyte (3 g H2SO4 and 3 g PVA were added into 30 mL deionized water) for 60 min, and subsequently picked out for air-drying to evaporate the residual water in the electrolyte and polypropylene membrane. After that, the film electrodes were connected with conductive copper wire (∼0.2 mm in diameter) through conductive silver paste. A single piece of polypropylene membrane, sandwiched in between, was used as a separator to assembly the electrodes, then they were packaged together by PET film and pressed under a pressure of ∼1 MPa for 10 min, which can make the electrodes adhered tightly and facilitate the electrolyte penetrating into them.
![]() | (1) |
![]() | (2) |
![]() | (3) |
:
rGO = 1
:
3, 2
:
1 film electrodes at different magnifications, from which can be seen that film electrodes had a significant differences. In top-view SEM images (Fig. 2c and e), the ACs in AC/rGO composite films were coated with wavy and wrinkled rGO sheets layer by layer. The two-dimensional rGO sheets resembled adhesive to connect ACs together and provided a conductive bridge for ion transport. In addition, the surface became hillier with the increase of ACs proportion. Meanwhile, in the cross-section SEM images (Fig. 2d and f), we can observe the hierarchical structures of the composite films at the same magnification. Notably, the layer spacing was dramatically expanded by ACs (the thicknesses of composite films increased from 24 to 33 μm), which benefited to the infiltration and transmission of the electrolyte.
![]() | ||
Fig. 2 (a) TEM image of pure GO sheets; (b) SEM image of pure ACs; (c, e) top-view, (d, f) cross-section SEM images of AC : rGO = 1 : 3, 2 : 1 film electrodes at different magnification. | ||
The XPS spectra of C 1s peaks for GO and rGO were shown in Fig. 3a and b. Four peaks were deconvoluted from the XPS spectra and distributed in the binding energies of 284.9, 286.7, 288.9 eV, which corresponded to the C
C, C–O, –C
O and –COO– bonds, respectively.16,38,39 The results indicated the existence of oxygenated functional groups on the GO. Similar peaks were appeared in Fig. 3b, oxygenated carbon peaks markedly decreased compared with GO. The residual oxygen content is about 13.19% of the total element after chemical reduction of hydrazine hydrate. Although chemical reduction did not completely remove oxygen-containing functional groups, the flexibility and mechanical strength of AC/rGO films were well maintained.19 Additionally, the whole XPS spectra of GO and rGO were shown in Fig. 3c. From that we can see the peak of the O element decreased significantly after chemical reduction. Compared with the XPS spectrum of GO, a small peak (N 1s) appeared in the rGO spectrum, which was mainly due to the introduction of N element in the process of hydrazine hydrate reduction. Moreover, the calculated values of N element increased from 0.64% to 2.81%, which was beneficial for capacitance improvement. Fig. 3d showed Raman spectra of the AC/rGO composite films. Typically, the two first-order bands D and a G were focused at the wave number of ∼1335 cm−1 and ∼1590 cm−1. In general, D peaks were stronger than G peaks, which indicated the composites had incomplete graphene structure and a large number of defects. The intensity ratio (R = ID/IG) of D peak induced by disordered structure and G peak caused by graphite crystal were used to characterize the disorder degree or defects of carbonaceous structures. As shown in Fig. 3d, with the proportion of the ACs increased, the ID/IG ratio of different AC/rGO composites decreased slightly from 1.29 to 1.23, indicating that the degree of graphitization increased slightly.40 It might be suggested that there were noncovalent interactions (might be hydrogen bonds, van der Waals force) between the AC/rGO composites, resulting in a good combination and excellent mechanical properties.41,42
![]() | ||
| Fig. 3 High-resolution XPS spectra of C 1s peaks for (a) GO and (b) rGO; (c) the whole XPS spectra of GO and rGO; (d) Raman spectra of various ratios of the AC/rGO composites. | ||
The textural parameters of all samples were measured by typical N2 adsorption/desorption isotherm at 77.35 K. From Fig. 4a, we can see that a typical sharp increase was appeared at a P/P0 of 0.1, which was the characteristic of micropores of carbon-based material.32 In particular, pure AC and the composites of AC
:
rGO = 2
:
1 and AC
:
rGO = 1
:
1 had a significant increase of the adsorbed volume.43 The adsorption capacity improved significantly with the increase of the doping amount of ACs indicating that the surface area of AC/rGO composites increased dramatically with the increase feeding of porous ACs. The pore size distributions of all samples were shown in Fig. 4b. All samples were dominated by the micro size with radius around 0.5 to 0.8 nm, which contributed to the improvement of specific capacitance. Detailed information regarding the physical properties of all samples were listed in Table 1. The pure AC sample had the largest specific surface area due to its porous structure. Moreover, the specific surface area (SBET) of the AC/rGO composites doubled improved with the increase of AC proportion. Compared with others, the AC
:
rGO = 2
:
1 film electrodes exhibited the highest values for specific surface area and total pore volume at 931.8 m2 g−1 and 0.6021 cm3 g−1, respectively.
| Sample | SBET (m2 g−1) | Smic (m2 g−1) | Vtot (cm3 g−1) | Vmic (cm3 g−1) | Wp (nm) |
|---|---|---|---|---|---|
| a SBET: the specific surface area; Smic: the micropore surface area; Vtot: total pore volume; Vmic: micropore volume; Wp: average pore diameter. | |||||
| AC | 1204.0 | 914.7 | 0.7992 | 0.5053 | 0.568 |
AC : rGO = 2 : 1 |
913.8 | 807.6 | 0.6021 | 0.4637 | 0.573 |
AC : rGO = 1 : 1 |
552.0 | 495.1 | 0.4753 | 0.3062 | 0.578 |
AC : rGO = 1 : 2 |
202.0 | 182.3 | 0.1264 | 0.1038 | 0.563 |
AC : rGO = 1 : 3 |
104.5 | 79.91 | 0.0915 | 0.0559 | 0.578 |
| rGO | 89.81 | 78.99 | 0.0412 | 0.0338 | 0.579 |
:
rGO = 2
:
1 electrode showed much larger current and integral area. Further demonstration was tested and plotted in Fig. 5b, GCD curves of all electrodes showed triangular shape and the AC
:
rGO = 2
:
1 film electrodes had the longest time span, indicating that the doping amount of ACs had a dominant contribution to the electrochemical performances. Furthermore, the area specific capacitances were calculated from GCD measurements using eqn (1). As shown in Fig. 5c, it can be found that the area specific capacitances of AC
:
rGO = 2
:
1 electrode were about 486, 420, 374, 337, 309 and 286 mF cm−2 at current densities of 0.2, 0.5, 1, 2, 3 and 5 mA cm−2, respectively. The highest area specific capacitance could reach 486 mF cm−2 with a mass of 2.35 mg cm−2 (specific capacitance of 207 F g−1), which were much higher than others. The poor electrical conductivity of pure rGO film electrode could be ascribed to its compact lamellar structure in the process of vacuum extraction, which could prevent the transmission of electrolyte ions to some extent. We further used impedance spectroscopy to investigate film electrodes. Fig. 5d depicted the Nyquist plot starts from the Z′-axis and progresses almost vertically to the Z′′-axis at the low frequency, indicating that the ideal capacitive characteristics of the electrodes. According to the semicircle intercepts of Z′, the charge transfer resistances (Rct) of the AC
:
rGO = 2
:
1, 1
:
1, 1
:
2 and 1
:
3 film electrodes were 2.90, 3.82, 2.74 and 3.90 Ω, respectively. The corresponding total resistance (R) of the film electrodes were 5.56, 6.59, 5.61 and 6.86 Ω, respectively. In contrast, the pure rGO electrode had a large total resistance of 12.87 Ω, indicating that AC/rGO film electrodes with lower resistance had good conductivity. These results could be explained by synergistic effects of active materials: (i) the addition of ACs expanded the layer space and prevented the stacking of rGO sheets; (ii) the flexible connection of rGO sheets provided a conductive bridge for ACs; (iii) such a 3D AC/rGO composite films without any binders had a large specific surface area and good electrochemical performance, which could be used as flexible electrode directly.
In order to explore the electrochemical performances in practical application, a flexible supercapacitor with the optimal ratio of AC
:
rGO = 2
:
1 electrodes had been assembled and characterized. Fig. 6a showed CV curves of the flexible supercapacitor measured from 0 to 1.0 V at various scan rates. All of CV curves afforded deformed rectangular-like shapes even at high scan rates, which elucidated the ideal capacitive and fast charge/discharge behavior of the flexible supercapacitor. Meanwhile, GCD curves at different current densities were recorded to further evaluate the performance. Fig. 6b showed that the charging/discharging curves were nearly symmetric triangular shape with their corresponding discharging counterparts, further demonstrating an ideal capacitive behavior of the device. The area specific capacitances of flexible supercapacitor were calculated using eqn (1) and plotted in Fig. 6c. From that we can see the highest area specific capacitance was 116.8 mF cm−2 at current density of 0.2 mA cm−2. Upon increasing the current density up to 5 mA cm−2, the specific capacitance retained about 52.6% of its original value. Additionally, approximately 85% capacitance was retained after 10
000 charging/discharging cycles at the current density of 5 mA cm−2, indicating an excellent stability and efficacy of the rapid electron transfer during charge/discharge processes. A comparison of the energy and power density of flexible supercapacitor with various reported rGO composites was given in Fig. 6d. According to the eqn (2) and (3), the calculated energy density was 16.2 μW h cm−2 at a power density of 100 μW cm−2 at current density of 0.2 mA cm−2. Evidently, the performance of AC/rGO flexible device was superior to others, such as GF/3D graphene network fibre (100 μW cm−2, 0.17 μW h cm−2),46 rGO/cellulose paper (60 μW cm−2, 15 μW h cm−2),47 polymer-wrapped rGO fibre (20 μW cm−2, 5.91 μW h cm−2),48 rGO/MnO2 paper (3800 μW cm−2, 11.5 μW h cm−2).49
:
rGO = 2
:
1, AC
:
rGO = 1
:
1, AC
:
rGO = 1
:
2, AC
:
rGO = 1
:
3). With the increase of the doping amount of ACs, the area specific capacitance increased significantly. Based on the premise of ensuring the formation of flexible film, the optimal ratio (AC
:
rGO = 2
:
1) were determined and the film electrode could deliver a superior area specific capacitance of 486 mF cm−2 with a mass of 2.35 mg cm−2 (specific capacitance of 207 F g−1) at 0.2 mA cm−2. The assembled double layer flexible AC/rGO supercapacitor reached high energy density of 16.2 μW h cm−2 at a power density of 100 μW cm−2 at 0.2 mA cm−2, and its capacitance retention up to 85% after 10
000 charging/discharging cycles. Moreover, 90% of the capacitance was retained after 1000 bending cycles at 5 mA cm−2 and almost no performance changed under different bending angles. Overall, these results well demonstrated that our flexible AC/rGO electrode is a promising candidate for assembling environment friendly, low price, ultrathin and flexible supercapacitors in wearable and portable electronic applications.
| This journal is © The Royal Society of Chemistry 2017 |