Subhasish Das*ab,
Maria Alice Zarur Coelhoa,
Priscilla F. F. Amarala and
Jayeeta Sila
aDepartment of Biochemical Engineering, Federal University of Rio de Janeiro, Brazil
bTriphase Pharmaceuticals Pvt. Ltd., Mysore – 570016, India. E-mail: sdas@triphasepharma.com; Tel: +91-821-4191022
First published on 3rd August 2017
Yarrowia lipolytica has drawn attention from the scientists over the last few decades because of its potential to accumulate intracellular lipid that can be transesterified to methyl esters with properties resembling those of diesel. A kinetics study of intracellular lipid production in Y. lipolytica is very important because it would help process modeling and cost minimization for increasing the lipid production. A set of defined media with varying amounts of pure glycerol as the carbon source and a fixed amount of ammonium sulfate as the nitrogen source and other media components, including thiamine and uracil supplements, was used to study the kinetics of lipid production. With an increase in the carbon to nitrogen (C/N) ratio, lipid accumulation increased to a certain limit up to 4 g L−1, followed by substrate inhibition. The best rate and amount of lipid accumulation was predicted to be obtained in a cultivation medium with an initial glycerol concentration of 93 g L−1. While lipid production was high, citric acid production in the media was negligible. Minimization of citric acid synthesis via proper media development with nitrogen starvation and unique supplement utilization can increase lipid accumulation in Y. lipolytica IMUFRJ 50682 up to a great extent in mere batch cultivation without any genetic modification.
Although glycerol alone can support the growth of yeast to some extent,11 addition of supplements can improve the production of lipid and citric acid along with biomass growth.4,6 In this study, Y. lipolytica IMUFRJ 50682 was chosen because it could produce good amounts of citric acid as well as lipid to some extent.3,5 Yarrowia lipolytica (IMUFRJ 50682) is a wild-type strain isolated from an estuary in the vicinity of Rio de Janeiro, Brazil (Haegler and Mendonça-Haegler, 1981). It was identified by the Instituto de Microbiology of the Health Sciences Center of the Federal University of Rio de Janeiro.12,13 Glycerol as a carbon substrate and ammonium sulfate as a nitrogen source were used instead of glucose (C) and yeast extract (N) because of the following reasons. (1) Lipids are essentially triglycerides of long chain fatty acids. Therefore, it is hypothesized that if Y. lipolytica can consume glycerol as a carbon source, the yield of lipid should increase since the forward reaction should accelerate. Lipid synthesis using glycerol as a carbon source occurs directly through the formation of glycerol-3-phosphate,3,9 requiring less metabolic energy as compared to glucose metabolism. (2) Catabolism of lipids produces free fatty acids, such as citric acid,3,5,9 as a valuable by-product. (3) Glycerol is abundantly available as a by-product of biodiesel production via transesterification of vegetable oil.1,2,14 (4) Complex media components, such as yeast extract, in the cultivation media for culturing yeast5,6 can act as a sole carbon source, nitrogen source and source of vitamins and minerals. These components would cause confusion while drawing any definitive conclusion over the experimental results obtained from this kinetic study. (5) Production of microbial lipid for obtaining biodiesel using lipid (e.g., industrial fats and vegetable oil) as a carbon source15,16 may not always be an attractive strategy in the emerging biofuel industry.
Herein, the effects of C/N ratio in a defined medium with varying initial concentrations of glycerol (as a carbon source) and ammonium salt (as a nitrogen source), along with thiamine and uracil supplementation, on lipid and citric acid production by Yarrowia lipolytica IMUFRJ 50682 have been studied.
A 24 h culture of Y. lipolytica IMUFRJ 50682 in GPY (2% glucose, 2% peptone, and 1% yeast extract) medium was used as inoculum, from which about 109 cells (1% of the defined medium) were inoculated in different conical flasks containing defined media with different concentrations of pure glycerol as abovementioned. The flasks were incubated in a shaker incubator under the following conditions: shaker speed 200 rpm, temperature 28 °C.
Citric acid concentration and residual glycerol concentration were measured using HPLC.14,19
Lipid droplet indices of the samples were measured by a method described by Morais et al.20 using the BODIPY fluorescent dye. Lipid was extracted and quantified by the chloroform–methanol method.18,21 Residual [NH4+] concentration was measured using a Himedia soil testing kit. A calibration curve was made using varying known concentrations of ammonium sulphate, and the resulting brownish solution was assayed at 700 nm (where the absorption maxima was found).
Microscopic analysis was performed using a phase-contrast microscope (Nikon Eclipse E200, Japan) with a 100 × 10 magnification.
Lipid extracted from Y. lipolytica IMUFRJ 50682 was analyzed via gas-chromatographic analysis to study its composition.18
Product yield upon biomass YP/X was calculated from the following equation:
All terms in each equation represent conventional meanings.
S0 (glycerol, g L−1) | Biomass (g L−1) | Total lipid (g L−1) | YP/S | Time of maximum yield |
---|---|---|---|---|
1.64 | 0.87 | 0.13 | 0.072 | 48 h |
6.80 | 3.42 | 0.57 | 0.094 | 48 h |
42.44 | 4.11 | 1.47 | 0.089 | 72 h |
92.83 | 5.89 | 4.17 | 0.104 | 100 h |
Beyond S0 = 92.83 g L−1, lipid yield gradually decreased (Fig. 2) although there was no detectable citric acid in these cultures. This observation did not agree with previous literature,6,7 where it was indicated that with the increasing C/N ratio, initially a proportional increase in the biomass yield was observed up to certain S0. Further increase in the C/N ratio causes intracellular lipid accumulation as well as extracellular citric acid production, which keeps on increasing up to an optimum C/N proportion, beyond which lipid accumulation decreases, but extracellular citric acid production keeps on increasing. Thiamine (a vitamin not synthesized by Y. lipolytica)-limited medium is known to help in the production of α-ketoglutaric acid and pyruvic acid, whereas thiamine-supplemented medium is supposed to induce citric acid production at low pH.3 Since Y. lipolytica IMUFRJ 50682 could produce as much as 8.64 g L−1 citric acid and 6.8% lipid upon biomass5 in a complex medium containing glucose, yeast extract, and other nutrients,11 in this study, it was expected that in the defined medium, the yeast should produce both citric acid and lipid even though the yield may be lower than in the complex medium. The complex medium containing yeast extract and peptone was used for inoculum medium preparation, but production medium used in this study was thiamine-supplemented defined medium. Initially, within the first 6–12 hours, pH decreased below 3.5 in all cultures with different S0 values and remained constant throughout likely because some or all of these organic acids were produced (data not shown in figure). There could hence be two possibilities: either citric acid excreted by the yeast cells was taken up as a carbon source,3 or citrate transporter proteins across cell membrane had been jeopardized. The first possibility does not seem to be practical as compared to the second possibility since in the first case, the cells have to spend more ATPs: once for excretion of citric acid and again for absorption of citric acid as a carbon source. Therefore, it is possible that inhibitors of citrate transport had been generated, which could be protein or peptide in nature.22 In the culture medium with S0 = 92.83 g L−1, it was observed in the culture samples at 24 h and 300 h that supernatant thiamine was intact (Fig. 3), whereas uracil was completely exhausted within the first few hours (not shown in figure). The effects of the supplements could be observed from the distinguishing cellular morphological features of 100 h old cultures of the yeast with supplements in the culture medium (Fig. 4A) and without supplements in the culture medium (Fig. 4B). With supplements, polar lipid accumulation in cell membranes was less prominent, indicating a need to synthesize cellular machinery to withstand physiological stress due to high glycerol concentration by exploiting the excess glycerol intake.
![]() | ||
Fig. 2 Effect of initial glycerol concentration, S0 (with fixed nitrogen concentration) in culture media on lipid (L) and biomass (X) yields. |
![]() | ||
Fig. 4 Phase contrast images of the 100 h old samples (A) with supplements in culture medium and (B) without supplements in culture medium. |
Media were prepared with and without thiamine and/or uracil (Table 2) to find out changes in the lipid, citric acid, and biomass yield, if any. However, total lipid yield did not decrease much, but citric acid yield was negligible. In fact, medium with thiamine and without uracil had a lipid yield of about 84% although the biomass yield decreased. Flask experiments do not generally produce much biomass because of oxygen limitation. Yarrowia lipolytica, being a strict aerobe, did not produce much biomass in the described experiments. However, it is to be noted that with increased oxygen supply, β-oxidation and catabolism of lipid is increased in Y. lipolytica (Alice et al. 2010).3 Therefore, oxygen limitation actually helped to reduce lipid loss in our study.
S0 (glycerol, g L−1) | Biomass (g L−1) | Total lipid (g L−1) | Time of maximum yield |
---|---|---|---|
92.83 (with uracil & thiamine) | 5.87 ± 0.12 | 4.19 ± 0.03 | 100 h |
92.83 (with thiamine, no uracil) | 5.21 ± 0.33 | 3.55 ± 0.15 | 100 h |
92.83 (no supplement) | 5.84 ± 0.10 | 3.6 ± 0.02 | 100 h |
This also led us to conclusion that yeast extract contains certain factor(s) other than thiamine or uracil that stops excretion of citric acid from cells or decreases lipid metabolism in this yeast by increasing citric acid secretion by the yeast cells. Citrate obtained from the TCA cycle can either be excreted as citric acid or can start lipid biosynthesis by forming acetyl Co-A and using ATP:citrate lyase (ACL) and other enzymes. In the present defined media, lipid yield increased because blockage of the extracellular citric acid production led to enhanced lipid accumulation (Fig. 5) via the ATP:citrate lyase (ACL) pathway.3,4,8–10,23 As abovementioned, with genetic modification, lipid accumulation can increase by as much as 90% of oleaginous yeast biomass .10 Our findings of over 70% lipid accumulation without genetic modification are really interesting in this context.
![]() | ||
Fig. 5 Schematic showing how suppression of citrate excretion from yeast cells might cause excess lipogenesis. |
Lipid compostion analysis from IMUFRJ 50682 showed predominance of oleic acid (46.8%), followed by palmitoleic acid (18%), palmitic acid (13.5%) (Table 3). A higher percentage of oleic acid in lipid would is desirable for biodiesel production.7,18 In this context it would be noteworthy to compare other reports on Y. lipolytica fatty acid compostion. Kamzolova et al. (2011) observed that the limitation of Y. lipolytica grown on glycerol-containing waste from biodiesel industry would result in biomass production enriched lipids (29.9% of dry biomass in growth phase). It was observed that the lipids of Y. lipolytica, grown on crude glycerol, were represented mainly by oleic, linoleic, palmitic and palmitoleic acids. But during the transition of citric acid-formation phase a significant alteration of the fatty acid composition happened; the content of oleic (Δ9C18:1) and palmitic (C16:0) acids decreased from 61.8 to 56.8% and from 7.23 to 4.57%, respectively, whereas the amount of palmitoleic acid (Δ9C16:1) increased from 1.8 to 9.03%. The amount of linoleic acid (Δ9,12C18:2) did not markedly change. High values of a C18:1/C18:0 ratio revealed in all variants were indicative of high activity of Δ9-desaturase, especially in the citric acid production phase.24 Another study revealed that the fatty acid composition of intracellular lipids in Y. lipolytica, grown on rapeseed oil was similar to that of rapeseed oil with predominance of oleic (Δ9C18:1) and linoleic (Δ9,12C18:2) acids (61.9 and 29.2% of the total fatty acids, respectively).25
Sara et al. (2016) observed the significant lipid could be produced (13.6 g L−1 and lipid content 52.7%) with wild strain Y. lipolytica grown on crude glycerol based media. They also reported that the yeast lipid contained mainly oleic, palmitic, linoleic and stearic acids and indicated that this lipid would be ideal for the synthesis of biodiesel.7
This journal is © The Royal Society of Chemistry 2017 |