Comparison of characteristics and limits of detection of pneumatic micronebulizers and a conventional nebulizer operating at low uptake rates in ICP-AES

Abstract

Three micronebulizers, the high-efficiency nebulizer (HEN), the microconcentric nebulizer (MCN) and the micromist (MM), were compared with a conventional pneumatic concentric nebulizer working at low liquid flow rates in ICP-AES. The gas back-pressure, the free liquid aspiration rate, the drop size distribution of primary and tertiary aerosols, the solvent and analyte transport rates, the emission intensity and the limits of detection were measured. The solvent evaporation inside the spray chamber proved to be a very important transport phenomenon when working at very low liquid flow rates. The micronebulizers produced finer primary aerosols, higher solution transport rates through the spray chamber and higher sensitivities than the conventional pneumatic concentric nebulizer. The HEN used in this work provided slightly lower ICP-AES limits of detection than the other two micronebulizers, but at the expense of a higher back-pressure.

References

1. Sample Introduction in Atomic Spectroscopy, ed. J. Sneddon, Elsevier, New York, 1990, p. 1.
2. G. M. Hieftje, J. Anal. At. Spectrom., 1996, 11, 613.
3. A. Montaser, M. G. Minnich, J. McLean, H. Liu, J. A. Caruso and C. W. McLeod, in Inductively Coupled Plasma Mass Spectrometry, ed. A. Montaser, Wiley-VCH, New York, 1998, p. 83.
4. J. W. Olesik, J. A. Kinzer and B. Harkleroad, Anal. Chem., 1994, 66, 2022.
5. H. Liu and A. Montaser, Anal. Chem., 1994, 66, 3233.
6. H. Liu, R. H. Clifford, S. P. Dolan and A. Montaser, Spectrochim. Acta, Part B, 1996, 51, 27.
7. H. Liu, A. Montaser, S. P. Dolan and R. S. Schwartz, J. Anal. At. Spectrom., 1996, 11, 307.
8. S. H. Nam, J. S. Lim and A. Montaser, J. Anal. At. Spectrom., 1994, 9, 1357.
9. S. A. Pergantis, E. M. Heithmar and T. A. Hinners, Anal. Chem., 1995, 67, 4530.
10. J. A. Kinzer, J. W. Olesik and S. V. Olesik, Anal. Chem., 1996, 68, 3250.
11. Q. Lu, S. M. Bird and R. M. Barnes, Anal. Chem., 1995, 7, 2949.
12. J. A. McLean, H. Zhang and A. Montaser, Anal. Chem., 1998, 70, 1012.
13. J. A. McLean, M. G. Minnich, L. A. Iacone, H. Liu and A. Montaser, J. Anal. At. Spectrom., 1998, 13, 829.
14. C. B'Hymer, K. L. Sutton and J. Caruso, J. Anal. At. Spectrom., 1998, 13, 855.
15. Meinhard Associates Web Site, http://www.meinhard.com, December 1998.
16. M. Vanhaecke, M. Van Holderbeke, L. Moens and R. Dams, J. Anal. At. Spectrom., 1996, 11, 543.
17. S. Augagneur, B. Medina, J. Szupnar and R. Lobinski, J. Anal. At. Spectrom., 1996, 11, 713.
18. C. Dubuisson, E. Poussel and J. M. Mermet, J. Anal. At. Spectrom., 1997, 12, 281.
19. J. L. Todolí, J. M. Mermet, A. Canals and V. Hernandis, J. Anal. At. Spectrom., 1998, 13, 55.
20. J. L. Todolí and J. M. Mermet, J. Anal. At. Spectrom., 1998, 13, 727.
21. T. D. Hettipathirana and D. E. Davey, J. Anal. At. Spectrom., 1998, 13, 483.
22. M. De Wit and R. Blust, J. Anal. At. Spectrom., 1998, 13, 515.
23. A. Woller, H. Garraud, J. Boisson, A. M. Dorthe, P. Fodor and O. F. X. Donard, J. Anal. At. Spectrom., 1998, 13, 141.
24. E. Debrah, S. A. Beres, T. J. Gluodenis, Jr., R. J. Thomas and E. R. Denoyer, At. Spectrosc., 1995, 16, 197.
25. K. A. Taylor, B. L. Sharp, D. J. Lewis and H. M. Crews, J. Anal. At. Spectrom., 1998, 13, 1095.
26. CETAC Technologies Web Site, http://www.cetac.com, November 1998.
27. Glass Expansion Web Site, http://www.glassex.com.au, November 1998.
28. R. I. Botto and J. J. Zhu, J. Anal. At. Spectrom., 1996, 11, 675.
29. CETAC Technologies Applications Bulletin, 003MCN1196U, CETAC Technologies, Omaha, NE, 1997.
30. K. E. Lawrence, G. W. Rice and V. A. Fassel, Anal. Chem., 1984, 56, 289.
31. D. R. Wiederin and R. S. Houk, Appl. Spectrosc., 1991, 45, 1408.
32. S. C. K. Shum, S. K. Johnson, H. Pang and R. S. Houk, Appl. Spectrosc., 1993, 47, 575.
33. J. S. Crain and J. T. Kiely, J. Anal. At. Spectrom., 1996, 11, 525.
34. D. R. Wiederin, F. G. Smith and R. S. Houk, Anal. Chem., 1991, 63, 219.
35. M. A. Tarr, G. Zhu and R. F. Browner, Anal. Chem., 1993, 65, 1689.
36. L. Wang, S. W. May, R. F. Browner and S. H. Pollock, J. Anal. At. Spectrom., 1996, 11, 1137.
37. D. D. Smith and R. F. Browner, Anal. Chem., 1982, 54, 533.
38. R. F. Browner, A. Canals and V. Hernandis, Spectrochim. Acta, Part B, 1992, 47, 659.
39. A. H. Lefebvre, Atomization and Sprays, Hemisphere, New York, 1989.
40. B. L. Sharp, J. Anal. At. Spectrom., 1988, 3, 613.
41. A. Kundt and E. Warburg, Ann. Phys., 1975, 155, 337.
42. A. Canals, V. Hernandis and R. F. Browner, J. Anal. At. Spectrom., 1990, 5, 61.
43. J. L. Todolí, A. Canals and V. Hernandis, Spectrochim. Acta, Part B, 1993, 48, 373.
44. D. E. Nixon, Spectrochim. Acta, Part B, 1993, 48, 447.
45. 2600 Laser Diffraction User Manual, Malvern Instruments, Malvern, 1987.
46. J. W. Olesik and J. C. Fister, Spectrochim. Acta, Part B, 1991, 46, 869.
47. A. Canals, V. Hernandis and R. F. Browner, Spectrochim. Acta, Part B, 1990, 45, 591.
48. J. W. Olesik, presented at the 1999 European Winter Conference on Plasma Spectrochemistry, Pau, France, 10–15 January, 1999.
49. T. D. Hettipathirana and D. E. Davey, Appl. Spectrosc., 1996, 50, 1015.
50. J. W. Olesik, J. A. Kinzer, J. Hartshorne and A. Jeffery, presented at the 1998 Winter Conference on Plasma Spectrochemistry, Scottsdale, AZ, January 5–10, 1998.
51. I. I. Stewart and J. W. Olesik, J. Anal. At. Spectrom., 1998, 13, 1249.
52. J. M. Mermet, Spectrochim. Acta, Part B, 1989, 44, 1109.
53. E. Poussel, J. M. Mermet and O. Samuel, Spectrochim. Acta, Part B, 1993, 48, 743.