Gas dynamics of the ICP-MS interface: impact pressure probe measurements of gas flow profiles

(Note: The full text of this document is currently only available in the PDF Version )

Terry N. Olney, Wei Chen and D. J. Douglas


Abstract

A versatile ICP-vacuum interface was constructed to investigate the gas dynamics and gas flow profiles of the ICP-MS interface. This new interface combines a low interface pressure, ≥0.24 Torr, with the ability to accommodate a variety of skimmer designs at sampler to skimmer spacings up to 80 mm. Plasma beams were extracted by placing a 0.9 or 2.0 mm diameter skimming orifice at distances of 6.7-47 mm behind the sampling orifice. Gas flow profiles of each resulting plasma beam were measured using an impact pressure probe placed at distances of 35-105 mm behind the skimmer. The centreline flux and width of the gas beam were compared with those calculated for an ideally skimmed beam. The results for the 0.9 mm diameter skimmer orifice showed that placing the skimmer at 17.0 and 27.3 mm downstream of the sampler formed the highest intensity and narrowest beams. In contrast, by placing the skimmer closer to the sampler, as in common interface designs, the beam profile is less intense on the centreline and much wider. Using a larger 2.0 mm diameter skimming orifice at 16.5-26.8 mm downstream of the sampler produced a more intense beam than any arrangement using the 0.9 mm skimming orifice. However with the 2.0 mm diameter skimmer, centreline intensities were still about half those of an ideally skimmed beam.


References

  1. D. J. Douglas and J. B. French, Anal. Chem., 1981, 53, 37 CAS.
  2. R. Campargue, Rev. Sci. Instrum., 1964, 35, 111 CAS.
  3. R. Campargue, Entropie, 1969, 30, 15 Search PubMed.
  4. R. Campargue, J. Chem. Phys., 1970, 52, 1795 CrossRef CAS.
  5. R. Campargue, Thesis, Faculty of Sciences, University of Paris, 1970.
  6. R. Campargue, in Proceedings of the 6th International Symposium of Rarefied Gas Dynamics, ed. G. Trilling and H. Y. Wachman, Academic Press, New York, 1969 Search PubMed.
  7. H. C. W. Beijerinck, R. J. F. Van Gerwen, E. R. T. Kerstel, J. F. M. Martens, E. J. W. Van Vliembergen, M. R. Th. Smits and G. H. Kaashoek, Chem. Phys., 1985, 96, 153 CrossRef CAS.
  8. (a) D. J. Douglas and J. B. French, J. Anal. At. Spectrom., 1988, 3, 743 RSC; (b) D. J. Douglas, in Inductively Coupled Plasmas in Analytical Spectrometry, ed. A. Montaser and D. W. Golightly, VCH, New York, 1992, p. 613 Search PubMed; (c) S. D. Tanner and D. J. Douglas, in Inductively Coupled Plasma Mass Spectrometry, ed. A. Montaser, Wiley-VCH, New York, 1998 Search PubMed.
  9. H. Niu and R. S. Houk, Spectrochim. Acta, Part B, 1996, 51, 779 CrossRef.
  10. H. Niu and R. S. Houk, Spectrochim. Acta, Part B, 1994, 49, 1283 CrossRef.
  11. B. S. Duersch, Y. Chen, A. Ciocan and P. B. Farnsworth, Spectrochim. Acta, Part B, 1998, 53, 569 CrossRef.
  12. D. J. Douglas, paper presented at the Annual Meeting of the Federation of Analytical Chemistry and Spectroscopy Societies, Cincinnati, OH, October 1995, paper 216.
  13. (a) G. R. Gilson, D. J. Douglas, J. E. Fulford, K. W. Halligan and S. D. Tanner, Anal. Chem., 1988, 60, 1472 CrossRef; (b) S. D. Tanner, Spectrochim. Acta, Part B, 1992, 47, 809 CrossRef.
  14. (a) S. D. Tanner, L. M. Cousins and D. J. Douglas, Appl. Spectrosc., 1994, 48, 1367 CAS; (b) S. D. Tanner, D. J. Douglas and J. B. French, Appl. Spectrosc., 1994, 48, 1373 CAS.
  15. J.-F. Ying and D. J. Douglas, Rapid Commun. Mass Spectrom., 1996, 10, 649 CrossRef CAS.
  16. J. B. French, in Molecular Beams for Rarefied Gas Dynamic Research, ed. W. D. Nelson, AGARDograph 12, NATO-AGARD Fluid Dynamics Panel, Paris, 1966 Search PubMed.
  17. K. R. Enkenhus, PhD thesis, University of Toronto, 1957.
  18. (a) G. E. McMichael and J. B. French, Phys. Fluids, 1966, 9, 1419 CrossRef; (b) A. L. Gray, J. Anal. At. Spectrom., 1989, 4, 371 RSC.
  19. J. E. Fulford and D. J. Douglas, Appl. Spectrosc., 1986, 40, 971 CAS.
Click here to see how this site uses Cookies. View our privacy policy here.