Organic vapor detection using quartz crystal sensors coated by sputtering of porous sintered-polymer targets

(Note: The full text of this document is currently only available in the PDF Version )

Iwao Sugimoto


Abstract

A lipophilic hydrocarbon–polymeric film applicable to hydrocarbon gas sensing at the ppm level was prepared by radiofrequency sputtering of a porous sintered-polyethylene (PE) disk on to an AT-cut quartz crystal resonator as a mass transducer. The hydrocarbon polymeric structure was confirmed by hydrogen forward scattering–Rutherford backscattering spectroscopy and X-ray photoelectron spectroscopy. This thickness-shear mode acoustic wave sensor was also sensitive to polar organic vapors owing to the incorporation of 8% of oxygen. Fluoropolymer films without oxygen can also be produced by rf sputtering of a porous sintered-poly(vinylidene fluoride) (PVDF) disk. The sorption behaviors of the PE and PVDF films for 20 ppm primary alcohols showed proportional and inversely proportional relationships, respectively, with the polarizabilities of solute molecules. Although 100 ppm toluene vapor did not induce mechanical damping of the PE film owing to its swelling or softening, its sorption capacity strongly decreased during iterative sorption tests. However, 100 ppm ethanol vapor did not cause such an abrupt decrease in sorption capacity over 10-cycle iterative tests.


References

  1. I. Sugimoto, M. Nakamura and H. Kuwano, Sens. Actuators B, 1996, 35–36, 342 CrossRef.
  2. R. Geetha, A. Toriaki, S. Yashida, S. Nagaya and K. Fueki, J. Appl. Polym. Sci., 1989, 27, 1653 CAS.
  3. R. Foerch, N. S. McIntyre and D. H. Hunter, J. Polym. Sci., Part A: Polym. Chem., 1990, 28, 193 CrossRef CAS.
  4. E. C. Onyiriuka, L. S. Hersh and W. Hertl, J. Colloid Interface Sci., 1991, 144, 98 CrossRef CAS.
  5. E. Occhiello, M. Morra, G. Morini, F. Garbassi and P. Humphrey, J. Appl. Polym. Sci., 1991, 42, 551 CrossRef CAS.
  6. R. Foerch, G. Kill and M. J. Walzak, J. Adhes. Sci. Technol., 1993, 7, 1077 CAS.
  7. Y. Khairallah, F. Arefi, J. Amouroux, D. Leonard and P. Bertrand, J. Adhes. Sci. Technol., 1994, 8, 363 CAS.
  8. N. Martakis, M. Niaounakis and D. Pissimissis, J. Appl. Polym. Sci., 1994, 51, 313 CrossRef CAS.
  9. J. Hopkins, R. D. Boyd and J. P. S. Badyal, J. Phys. Chem., 1996, 100, 6755 CrossRef CAS.
  10. D. M. Choi, C. K. Park and C. E. Park, Polymer, 1997, 25, 6243 CrossRef.
  11. G. Z. Xiao, J. Adhes. Sci. Technol., 1997, 11, 655 CAS.
  12. M. Morra, E. Occhiello, L. Gilaand and F. Garbassi, J. Adhes., 1990, 33, 77 Search PubMed.
  13. N. Inagaki, Surf. Sci., 1997, 18, 543 CAS.
  14. CRC Handbook of Chemistry and Physics, ed. Weast, R. C., CRC Press, Boca Raton, FL, 1989 Search PubMed.
  15. Handbook of X-Ray Photoelectron Spectroscopy, ed. Muilenberg, G. E., Perkin-Elmer, Eden Prairie, MN, 1979 Search PubMed.
  16. G. Z. Sauerbrey, Z. Phys., 1959, 155, 206 CAS.
  17. V. Meces and R. V. Bucur, Thin Solid Films, 1979, 60, 73 CrossRef.
  18. D. M. Ullevig, J. F. Evans and M. G. Albrecht, Anal. Chem., 1982, 54, 2341 CrossRef CAS.
  19. W. H. Lawson, J. Sci. Instrum., 1967, 44, 917 Search PubMed.
  20. I. Sugimoto, M. Nakamura and H. Kuwano, Thin Solid Films, 1994, 249, 118 CrossRef CAS.
  21. I. Sugimoto, M. Nakamura and H. Kuwano, Sens. Actuators B, 1996, 37, 163 CrossRef.
  22. M. J. S. Dewer, E. G. Zoebisch, E. F. Healy and J. J. P. Stewart, J. Am. Chem. Soc., 1985, 107, 3902 CrossRef.
  23. T. E. Phillips, C. B. Bargeron and R. C. Benson, J. Vac. Sci. Technol. A, 1995, 13, 2726 CrossRef CAS.
  24. S. J. Martin and G. C. Frye, in IEEE Ultrasonics Symposium Proceedings, IEEE, New York, 1991, p. 393 Search PubMed.
  25. P. Hauptmann, R. Lucklum, J. Hartmann, J. Auge and B. Adler, Sens. Actuators A, 1993, 37, 309 CrossRef.
  26. T. Okajima, H. Sakurai, N. Oyama, K. Tokuda and T. Ohsaka, Electrochimica Acta, 1993, 38, 747.
  27. D. James, D. V. Thiel, G. R. Bushell, K. Busfield and A. Mackay-Sim, Analyst, 1994, 119, 2005 RSC.
  28. Y. Yin and R. E. Collins, Thin Solid Films, 1995, 257, 139 CrossRef CAS.
  29. F. A. M. Davide, C. D. Natale, A. D'Amico, A. Hieerlemeann., J. Mitrovics, M. Schweizer, U. Weimar, W. Göpel, S. Marco and A. Pardo, Sens. Actuators B, 1995, 26, 275 CrossRef.
Click here to see how this site uses Cookies. View our privacy policy here.