 Open Access Article
 Open Access Article
      
        
          
            Sebastian 
            Prodinger
          
        
       *a, 
      
        
          
            Izar Capel 
            Berdiell
*a, 
      
        
          
            Izar Capel 
            Berdiell
          
        
       a, 
      
        
          
            Tomas 
            Cordero-Lanzac
a, 
      
        
          
            Tomas 
            Cordero-Lanzac
          
        
       a, 
      
        
          
            Odd Reidar 
            Bygdnes
          
        
      a, 
      
        
          
            Bjørn Gading 
            Solemsli
a, 
      
        
          
            Odd Reidar 
            Bygdnes
          
        
      a, 
      
        
          
            Bjørn Gading 
            Solemsli
          
        
       a, 
      
        
          
            Karoline 
            Kvande
a, 
      
        
          
            Karoline 
            Kvande
          
        
       a, 
      
        
          
            Bjørnar 
            Arstad
a, 
      
        
          
            Bjørnar 
            Arstad
          
        
       b, 
      
        
          
            Pablo 
            Beato
b, 
      
        
          
            Pablo 
            Beato
          
        
       c, 
      
        
          
            Unni 
            Olsbye
c, 
      
        
          
            Unni 
            Olsbye
          
        
       a and 
      
        
          
            Stian 
            Svelle
a and 
      
        
          
            Stian 
            Svelle
          
        
       a
a
      
aCenter for Materials Science and Nanotechnology (SMN), Department of Chemistry, University of Oslo, 1033 Blindern, 0315 Oslo, Norway. E-mail: sebastian.prodinger@smn.uio.no
      
bSINTEF Industry, Forskningsveien 1, 0373 Oslo, Norway
      
cTopsøe A/S, Haldor Topsøes Allé 1, 2800 Kongens Lyngby, Denmark
    
First published on 28th September 2023
Mordenite (MOR) zeolite, an important industrial catalyst exists in two, isostructural variants defined by their port-size, small and large-port. Here we show for the first time how a systematic, single-parameter variation influences the synthesis out-come on the final MOR material leading to distinctly different catalysts. The cation identity has a direct impact on the synthesis mechanism with potassium cations generating the more constrained, small-port MOR variant compared to the large-port obtained with sodium cations. This was expressed by different degrees of accessibility ascertained with a combination of toluene breakthrough and temperature programmed desorption (TPD), propylamine TPD, as well as sterically sensitive isobutane conversion. Rietveld refinement of the X-ray diffractograms elucidated the preferential siting of the smaller sodium cations in the constricted 8-ring, from which differences in Al distribution follow. Note, there are no organic structure directing agents utilized in this synthesis pointing at the important role of inorganic structure directing agents (ISDA).
Mordenite zeolite was discovered as a mineral in Morden, Nova Scotia (Canada) by How in 1864 long before being synthesized hydrothermally in 1952.4–6 Mordenite is classified as a large-pore zeolite characterized by 12-rings that run along the c-axis, terminating at the [001] surface.7 Parallel to these 12-rings, there are highly compressed 8-rings with an aperture of 5.7 × 2.6 Å that are too small for molecules larger than 3.4 Å to enter. Orthogonally, along the b-axis there is another 8-ring with less distorted dimensions that intersects the compressed 8-ring channel and the 12-ring. It does not, however, create a two-dimensional system, as the 8-ring channels along the b-axis are staggered, making it impossible for large molecules to diffuse fully along the b-axis. Instead, the 8-ring channel along the b-axis is classified as a side-pocket that has been found to be highly selective for chemical transformations of small molecules such as dimethyl ether carbonylation and selective methane oxidation.8–11
A peculiarity of the mordenite zeolite is its existence in two variants, defined primarily by their port-size (i.e. the aperture of the pore system). This has been identified early on with the first mention of the phenomenon in the synthesis work by Sand.5 Small-port mordenite accepts less than 5 wt% of molecules larger than 4.2 Å (e.g. benzene) whereas large port mordenite achieves a higher uptake (>5 wt%/ca. 500 μmol g−1). Note that in both cases the crystal structure consists of 12-rings. Typical synthesis procedures for small-port mordenite involve high temperatures (275–300 °C), whereas the large-port mordenite can be crystallized at lower temperatures (<260 °C).5 Over the course of mordenite zeolite history, several tentative explanations for the origin of this feature have been proposed, such as localization of extra-framework cations, residual amorphous material in the pores, and stacking faults disrupting the continuity of the 12-ring channels.5,12 However, no conclusive evidence has been found to fully support one of these. It is noteworthy that dealumination leads to the opening of the framework transforming small-port into large-port mordenite.13 This points to the significance of Al placement within the framework.
Several studies have reported that among the 4 tetrahedral crystallographically non-equivalent sites, the T3 site (brown, Fig. 1) is preferentially occupied by Al.14,15 Simoncic & Armbruster found that in naturally occurring mordenite, Al in T3 has an occupancy of 0.41 while Al in T2 has an occupancy of only 0.03.15 This was associated with the high concentration of Ca2+ present in the material, which was found by structure refinement to be located within the center of the compressed 8-ring. The high charge localization had to be balanced by incorporating Al at the T3 position in the 8-ring.
|  | ||
| Fig. 1  MOR framework illustrated by its corner sharing tetrahedral of SiO4 and AlO4. The T-sites are color-coded:  ,  ,  ,  . (left) Shows the [001] surface while (right) shows the [010] surface. | ||
This preferential localization of the Al and resulting negative framework charge determines the subsequently generated acid site centers and more general ion exchange site locations. From this, a profound impact on acid-catalyzed transformations follows; in carbonylation reactions it has been found that the confined space of the 8-ring makes the transition state, required for a highly selective carbonylation of MeOH and DME, feasible in the first place.8,9 Acid sites in the 12-ring, instead lead to coking. Similarly, the small molecule methane is proposed to be activated on Cu-oxo sites situated in the confined spaces of the 8-ring side-pocket.10,11 We hypothesize that Al siting can also explain the port size variation observed for mordenite.
Influencing Al placement in zeolites has been an ongoing effort over the last decade.16–20 This typically involves exploiting the charge density mismatch between large organic ammonium cations and small inorganic cations. This works primarily for high-silica zeolites (Si/Al > 10). A challenge arises for systems with Si/Al < 10 (e.g. mordenite). Influencing Al placement during zeolite synthesis, as opposed to post-synthetic modification,21,22 can only be achieved by varying the inorganic species present (i.e. Si source, Al source, mineralizer agent).23,24 Our previous contribution studied the impact of the Al source in the case of MOR.25 Small pH variations led to speciation of the Al location in the final material, which allowed us to deduce a structure–activity relationship for production of methanol from methane upon exchanging copper into the zeolite.25
Here we propose an alternative approach to influence Al distribution by stimulating synthesis of crystalline mordenite in the presence of cations of different size, namely sodium and potassium cations. With this we aim also to resolve the issue of port-size variation in this highly relevant catalyst system.
Next, we introduced NaOH and systematically varied the Na+/K+ ratio in the synthesis gel, while keeping the overall hydroxide concentration constant. In all cases we achieved phase purity, assessed by X-ray diffraction (Fig. 2, top), albeit it requires prolonged periods as the K+ content in the gel increases (Fig. 2, bottom). The final materials had comparable Si/Al ratios (ca. 6.7–7.3, Table S1†). Based on the amount of K+ incorporated in the crystalline material relative to that in the gel, there is a clear preference for K+, as shown by the convex deviation from the parity line (Fig. 2, bottom).
A closer look at the crystallization curves for the two extremes, reveals discrete differences with respect to induction times and crystallization rates (Fig. S3†). We find that sodium increases both the nucleation and crystallization rate. Whereas K-MOR has an induction period of ca. 15 h, preparing the same synthesis gel solely with NaOH already yields 30% crystallinity at the same time. During the induction period, the gel achieves supersaturation and the secondary building units present become thermodynamically equilibrated after which it becomes feasible to start growing crystallites, rather than the nuclei being dissolved by the highly alkaline conditions.26,27 The end of the induction period, signaled by the detection of X-ray diffracting crystals (i.e. domains > 10 nm),28 is followed by a period of crystal growth where dissolved aluminosilicate and silicate species condense with the growing crystals. Here the rate of crystal growth is mainly determined by the rate of depolymerization/hydrolysis of the Si source and condensation with the nuclei and crystallites present. With crystallite size being comparable across all samples (vide infra), the number of nuclei formed must be similar and the difference in crystallization curve must come from a slower crystal growth rate for KOH. The rate of depolymerization (and condensation/hydrolysis reactions needed for zeolite formation in general) is influenced by the concentration of hydroxide ions (pOH) and is thus directly linked to the pH, as shown by us previously.25 And yet, the K-MOR system crystallizes more slowly despite having a somewhat higher gel pH (Table S1†). This suggests that the nature of the cation has an outsize effect on zeolite formation. Naturally, the concentration of hydroxide ions would influence the rate of formation, however, in such concentrated gels the ionic strength of the base cannot be neglected. In fact, the viscosity of the gels was notedly different depending on the mineralizing agent, with the Na-MOR gel having a lower viscosity. This suggests NaOH to be a stronger mineralizing agent, achieving a faster depolymerization of the SiO2, releasing H2O and as such achieving lower viscosity. It is conceivable that the highly fluid Na-MOR gel allows for a rapid solid/liquid transport, thus also favoring crystallization. Furthermore, the aluminosilicate oligomers are in close contact with the charge balancing alkali cations and the interaction strength of these ions will also influence the oligomers formed. NMR studies by McCormick et al. have shown how larger cations can stabilize larger silicate oligomers.29,30 The affinity towards water cannot be neglected either, as this will determine how easily aluminosilicate species can condense with one another by displacing water molecules in the cation's hydration sphere.31,32 Breynaert et al. have recently shown how cation–oligomer interactions (e.g. Na+vs. Cs+) can influence crystallization behavior in high-silica ionic liquids (HSIL),33,34 while Wakihara et al. showcased this for Cs+ in the RHO framework.35 In addition, Okubo et al. have previously observed an elongated crystallization time for K-FER relative to Na-FER, which they attributed to a less facile stabilization of small primary building units (e.g. 4-rings) in the FER system.36 We believe a similar effect to influence the crystallization behavior in mordenite (vide infra).
|  | ||
| Fig. 3 SEM images of a range of fully crystalline MOR zeolite with varying degrees of K incorporation. | ||
As the K-content in the gel increases the a-axis shrinks, increasing the aspect ratio to 0.49 for 0.5K-MOR and reaches unity as the morphology of the crystals becomes cubic for the 1K-MOR material. At the same time, the overall crystal size (volume assessed based on prismatic or cubic shape, Fig. S4†) remains comparable for all materials, despite a longer crystallization time for the K-enriched mordenite crystals. This suggests preferential facet growth in direction of the c-axis is taking place. We speculate this to be related to thermodynamically favored adsorption sites for soluble oligomers along the c-axis, stabilized by the K+ cations possibly due to their larger size. The structure directing role of cations has been postulated for other zeolites such as Na+ cations in FAU.31,32,37 This enrichment of potassium in the crystals occurs during synthesis and does not lead to a difference in Si/Al. For example, it is conceivable that the larger size of K+ cations will lead to less Al incorporated within the framework.33 With comparable Si/Al, this instead suggests a differentiation in where the Al is incorporated. Powder X-ray diffraction supports this hypothesis. The initial data across the samples already showed a clear trend in the structure factors variation for given reflections both in alkali-MOR and H-MOR (Fig. S5†). Thus, we decided to investigate this further on select samples, within a controlled environment of sealed borosilicate glass capillaries. We have repeatedly shown that it is possible to quantitatively determine the amount of coke or guest molecules inside the channels of the zeolite with Rietveld refinement of powder X-ray diffraction, by using dummy atoms as placeholders for residual electron density.38–40 Here we apply a similar approach for the alkali-MOR forms to achieve striking visual evidence of varying ion distribution, Fig. 4. As the cations – and by extension, the protons – are balancing the negative framework charge induced by framework Al this would strongly suggest a difference in the Al siting. Note this analysis is performed on flame sealed samples after water removal with refinement of hydrated samples resulting in a poorer fit (Fig. S6†). Dry K-MOR has two crystallographically unique alkali positions identical to the ones reported for rehydrated Ca-exchanged mordenite;41 site A, in the mouth of the side-pocket oriented towards the big 12-ring channel and site B, in the compressed 8-ring channel. In contrast, Na-MOR has three positions, of which two are in the compressed 8-ring channel and the last is very similar to site A of K-MOR.
While the Fourier maps suggest that site B is preferential in the Na-MOR, the residual electron density attributed to K+ ions is split more evenly between the 8-ring (site B) and 12-ring (site A). This might suggest that the steric constraint of a larger cation drives more of these charges to lie towards the 12-ring. Rietveld refinements now including Na+ and K+ in the models (see Fig. S6† to evaluate the quality of the fits) indicated that the distribution of the cations described as site A/B ratio, varies across the series accordingly; 1.01 for K-MOR, 0.72 for 0.5K-MOR and 0.39 for Na-MOR. Note, this trend follows the aspect ratio c/a ascertained by SEM, supporting the claim that larger K+ cations in site 1 favor crystal growth in c direction while site 2 favors the a direction. Indeed, this difference in crystal shape can also be observed when considering anisotropic crystallite shape parameters during Rietveld refinement. While they are typically limited to sizes of 100 nm,42 their inclusion for the more prismatic crystals of Na-MOR did improve the fit and does suggest a shrinking of the crystal shape in the c direction.
The presented powder diffraction data does not contain enough information to refine aluminum occupancies across T sites. However, assuming equivalence between alkali cations and Al allows us to measure a total amount of 5.4 potassium cations per unit cell, equal to a Si/Al ratio of 7.8. For the 0.5K-MOR and 1Na-MOR samples the Si/Al ratios are 5.9 and 6.2, respectively, agreeing sufficiently well with MP-AES results (Table S1†). Based on the two sites defined for K-MOR we used a rough estimation correlating these M+ sites with nearby T-sites (Fig. S7 and Table S2†). Interestingly, Fan et al. using 23Na MAS NMR claimed to observe 3 sodium sites: I, IV & VI and assigned them to T3, T4 and T1+2 respectively,43 however, we do not see any evidence of electron density around position VI (12-ring).
We can then use the occupancies of M+ in sites A and B to speculate about a different aluminum distribution, with total amount of M+ equaling Al. Site A is related to T2 & T4 while T3 & T1 are closer to site B. In reality the situation is more complicated because T1, although far away from site A, is also part of the 12-ring and oxygen bridging between T3 & T4 is arguably close to both M+ sites. As Al will occupy T-sites that are energetically most favored, our site A/B ratio obtained from refinement allows us to propose occupancies for T3 that go from 0.18 in the K-MOR to 0.33 in Na-MOR, while T4 for example is 0.20 in K-MOR and 0.14 in the Na-MOR. Note that while the T3 occupancy for Na-MOR is close to that reported in literature, we need to stress that this is based solely on electrostatic logic and only describes the Al distribution trend, rather than being an absolute numerical answer.
Lastly, there is a clear progression for the lattice parameters in both dry and hydrated states that suggests a major structural change when the big alkali cations are present (Fig. S8†).
|  | ||
| Fig. 5 Ar physisorption isotherms (top) and pore size distributions (bottom) obtained at 87K for a select number of samples (Na-MOR, K-MOR, H-MOR (K)). | ||
|  | ||
| Fig. 6 Toluene breakthrough curves for synthesized MOR in the alkali form (top) and the protonic form (bottom). | ||
| Sample | Toluene (μmol g−1) | TolueneTPD (μmol g−1) | TolueneSi | 
|---|---|---|---|
| 1K-MOR | 264 | 232 | 7.8% | 
| 0.5K-MOR | 452 | 317 | 11.0% | 
| 1Na-MOR | 531 | 464 | 13.4% | 
| Na-SSZ-13 | 219 | 28 | n/a | 
| NaCBV10Ads | 522 | 371 | 15.4% | 
Over the years, several hypotheses have been put forward to explain the port-size variation, such as amorphous silica residue in the pores, defects in the crystal planes due to stacking faults – limiting passage, and extra-framework cations.5,12,51 We first noted differences in the pore accessibility when interrogating the materials with N2-physisorption, which is very sensitive to extra-framework species (see Fig. S10,† bottom). For the alkali-MOR, the larger K+ led to a low porosity material, suggesting that extra-framework cations can indeed influence the port size. Alternatively, one could argue that the K-MOR zeolites are prone to deposits of amorphous silica. However, we can exclude both the role of cations and the presence of amorphous silica as the H-forms of the prepared materials were highly porous in all cases when probed with N2. We see a similar behavior when investigating toluene breakthrough, comparing toluene adsorption on both alkali- and H-forms. In the latter case, more toluene is adsorbed (e.g. 530 μmol g−1vs. 700 μmol g−1 for 1Na-MOR) which matches the increase in porosity. However, this study is also proof that port-size cannot be ascertained by N2-physisorption alone, as the corresponding 1K-MOR sample experiences no increased toluene uptake when being transformed into the H-form.
We also exclude the role of defects. Stacking faults are associated with a higher concentration of silanol defects which can be identified by hydroxyl vibrations.52,53 Due to the large crystal size we applied a surface sensitive IR technique – DRIFTS – to compare the 1K-MOR and 1Na-MOR samples (Fig. S12†). However, we find no discernible differences between the two materials, other than perhaps that the H-MOR (Na) presents a slightly more intense band due to higher concentration of acid sites (3600 cm−1), and one could argue that the shoulder corresponding to external silanols (3735 cm−1) is marginally more pronounced.
Recently, Gao et al. have purported a simple technique to investigate framework Al in the channel intersections of ZSM-5.54 Performing a temperature programmed desorption with toluene on Na-exchanged ZSM-5, they were able to differentiate between toluene adsorbed on the siliceous pore wall and on framework Al (i.e. Brønsted acid sites).54 This differentiation can only be done due to the strong interaction between toluene and alkali cations and upon introducing an isothermal step at low temperature (100 °C). On the H-form, both adsorption sites are closer in strength resulting in peak overlap. Utilizing their approach, we observe similar features on the MOR system. The TPD profiles for the H-forms (Fig. S11†) present a low temperature shoulder, which we were able to resolve when using the alkali-MOR and a stepwise TPD profile. Clearly, a low temperature peak is observed for species held only weakly within the pores. Note, prior to the TPD, the sample is flushed for several hours in inert gas at 35 °C which removes some weakly bound toluene. This is evident when investigating the Na-SSZ-13 zeolite, which adsorbed 219 μmol g−1, but retained only a marginal amount of 28 μmol g−1 upon quantifying the desorbed toluene (Table 1), which follows from the large kinetic diameter of toluene (5.85 Å) relative to the 8-ring window of SSZ-13 (3.8 Å). Therefore, the amounts of desorbed toluene tend to be lower than those measured during the preceding breakthrough experiment.
Comparing the relative amount adsorbed on the siliceous pore wall to the toluene interacting with the framework Al in the 12-rings yields a crucial insight (Table 1). The small-port 1K-MOR has a much smaller fraction of toluene adsorbed on the siliceous pore wall (7.8%) compared to the large-port samples (13–15%). This is in agreement with the cation/Al siting results that imply a higher relative acid site concentration in the 12-ring for the K-MOR. There, a higher fraction of toluene will be interacting with cations, compared to the large-port, Na-MOR where most acid sites are located in the 8-ring.
Lastly, the shape of the breakthrough curve carries information relating to diffusional limitations.55,56 An ideal breakthrough curve has a clean front, indicating the absence of axial dispersion forces and intra-crystalline diffusion limitations such as that exhibited by SSZ-13 and 1K-MOR in Fig. 6. The large-port materials, on the other hand, present a more distended breakthrough curve, which implies the presence of diffusion limitations such as correlation effects between nearby adsorbed molecules.56 Note, that the Al–O bond is known to be slightly longer than the Si–O bond in zeolites (1.736 Å vs. 1.603 Å).57 This suggests that the higher concentration of Al in the side-pocket and 8-ring for the large-port mordenite likely expands this pore space. This allows for the pocketing of some toluene molecules interacting with cations and protons in these spaces, which increases their diffusion time and uptake capacity in the porous system.
However, the amount of NH3 released during the Hoffman elimination, is largely constant across all samples and in close agreement with the results from NH3-TPD (Tables S5 and S6†). This suggests the discrepancy between propene and NH3 for the K-enriched systems to originate from not all propene exiting the pore system. Dark coloration of the samples post-reaction, indicating coking, corroborates this. Interestingly, H-SSZ-13 (Si/Al 6), a small pore zeolite (8-ring windows) does not suffer from this carbon loss by coking, making our observation unique to the MOR framework, and more specifically unique to small-port mordenite. Indeed, when following the propylamine TPD with a subsequent temperature-programmed oxidation (TPO) step the coke can be oxidized to CO2. Quantification of the released CO2 allows us to account for a significant fraction of propene lost due to coking. A trend is clearly seen, evolved CO2 correlating with the amount of K in the gel during synthesis, i.e. the small port mordenites (Fig. 7). Meanwhile the small-pore SSZ-13 evolves only negligible amounts of CO2.
|  | ||
| Fig. 7 Correlation between the amount of coke produced during propylamine TPD and the amount of toluene adsorbed as a function of the potassium content in the synthesis gel. | ||
Most noteworthy, 1-dimensional zeolites (such as MOR, TON) favor the formation of linear oligomers over β-scission and isomerization reactions at 200–350 °C as investigated by Sarazen et al.59,60 They find that propene oligomerization rates increase dramatically with the pore constraints. These oligomers can then easily lead to the formation of coke by re-adsorption and protonation on nearby acid sites. We surmise the 8-ring windows in SSZ-13 – allowing access to a large cavity – to be insufficient to induce this oligomerization behavior. We aimed to reproduce the reported results, however, even at very low partial pressures of propene the deactivation was instantaneous (faster than equipment time resolution), irrespective of MOR tested (1K-MOR, 1Na-MOR), as reported in the ESI (Fig. S13†).
Additionally, the introduction of Al into specific locations likely also influences the flexibility and degree of distortion of pores. Researchers recently demonstrated how the adsorption of benzene can distort the 10-rings of ZSM-5 leading to a reversible 15% pore expansion.62,63 They related this to the flexibility of the Si–O–Si bond angles. Whether this facet of zeolite chemistry can have a profound influence on catalysis remains to be seen.64
We can thus conclude that Al-siting lies behind the mysterious behavior of mordenite port-size variation, with more Al in the 12-ring leading to a small-port material. In fact, the works by Marcilly et al. highlight how acidic leaching of Al as a means of dealumination can lead to the transformation of small-port to large-port MOR. Once ca. 20% of the tetrahedral Al are extracted, the material's benzene uptake increases dramatically.13 This supports our claim that the population of framework Al in specific sites affects the port-size.
It is conceivable that the large spread in performance data obtained on Cu-MOR for the stoichiometric methane to methanol reaction can be partially explained by the facile ability of pores to accommodate the creation of active Cu-oxo species.65–68 This simple approach of varying the Al location in MOR, elucidated here, will prove promising when investigating these materials for their performance in small molecule activation.
![[thin space (1/6-em)]](https://www.rsc.org/images/entities/char_2009.gif) :
:![[thin space (1/6-em)]](https://www.rsc.org/images/entities/char_2009.gif) 1Al2O3
1Al2O3![[thin space (1/6-em)]](https://www.rsc.org/images/entities/char_2009.gif) :
:![[thin space (1/6-em)]](https://www.rsc.org/images/entities/char_2009.gif) 16SiO2
16SiO2![[thin space (1/6-em)]](https://www.rsc.org/images/entities/char_2009.gif) :
:![[thin space (1/6-em)]](https://www.rsc.org/images/entities/char_2009.gif) 166H2O, where M stands for Na or K. In short, we first dissolve 7.67 g KOH (85% Sigma Aldrich) in 10 mL H2O followed by addition of 3.41 g Al(OH)3·H2O (50–57% Al2O3, Aldrich). The solution is stirred for 1 h before adding another 10 mL H2O and stirring for an additional hour. The solution should become clear. Finally, 12.6 mL H2O are added and the clear Al solution is slowly added to 52.5 g of Si sol (Ludox AS-40). The gel was then aged overnight under viscous stirring before being crystallized inside Teflon liners at 185 °C for 96 h. In the case of Na-MOR, the same procedure was followed, but using NaOH (Sigma Aldrich). The mixed Na, K systems maintained the overall molar amount of MOH, but varied the ratio between KOH/NaOH. After the sample was crystallized, the solid was separated from the supernatant by vacuum filtration and washed with hot water until the pH < 10. The samples are labeled based on the K-content in the gel (e.g. 0.75K-MOR is synthesized with 75 mol% KOH to 25 mol% NaOH for a total of 2.6M2O
166H2O, where M stands for Na or K. In short, we first dissolve 7.67 g KOH (85% Sigma Aldrich) in 10 mL H2O followed by addition of 3.41 g Al(OH)3·H2O (50–57% Al2O3, Aldrich). The solution is stirred for 1 h before adding another 10 mL H2O and stirring for an additional hour. The solution should become clear. Finally, 12.6 mL H2O are added and the clear Al solution is slowly added to 52.5 g of Si sol (Ludox AS-40). The gel was then aged overnight under viscous stirring before being crystallized inside Teflon liners at 185 °C for 96 h. In the case of Na-MOR, the same procedure was followed, but using NaOH (Sigma Aldrich). The mixed Na, K systems maintained the overall molar amount of MOH, but varied the ratio between KOH/NaOH. After the sample was crystallized, the solid was separated from the supernatant by vacuum filtration and washed with hot water until the pH < 10. The samples are labeled based on the K-content in the gel (e.g. 0.75K-MOR is synthesized with 75 mol% KOH to 25 mol% NaOH for a total of 2.6M2O![[thin space (1/6-em)]](https://www.rsc.org/images/entities/char_2009.gif) :
:![[thin space (1/6-em)]](https://www.rsc.org/images/entities/char_2009.gif) 1Al2O3) To obtain the protonic form of the zeolite the sample was first ion exchanged at 70 °C in 1.0 M NH4NO3 solution for 12 h. This was performed a total of three times, before calcining the dried NH4-form at 500 °C for 6 h in static air.
1Al2O3) To obtain the protonic form of the zeolite the sample was first ion exchanged at 70 °C in 1.0 M NH4NO3 solution for 12 h. This was performed a total of three times, before calcining the dried NH4-form at 500 °C for 6 h in static air.
        To obtain the protonic form of the zeolite the sample was first ion exchanged at 70 °C in 1.0 M NH4NO3 solution for 12 h. This was performed a total of three times, before calcining the dried NH4-form at 500 °C for 6 h in static air. In the case of the SSZ-13 zeolite the organic structure directing agent had to first be calcined, which was done by heating the as-made material to 550 °C in static air and holding it at this temperature for 6 h.
![[thin space (1/6-em)]](https://www.rsc.org/images/entities/char_2009.gif) 000 scans were collected. The spectra were referenced to an aqueous Al(NO3)3 solution. The samples were hydrated over saturated Ca(NO3)2 solution for 48 h prior to the measurement.
000 scans were collected. The spectra were referenced to an aqueous Al(NO3)3 solution. The samples were hydrated over saturated Ca(NO3)2 solution for 48 h prior to the measurement.
        NH3 TPD was performed on the NH4-Form of select samples to quantify the total amount of NH3 released during the in situ generation of the H-Form. The sample was heated to 650 °C (10 °C min−1, 66 mL min−1 N2) and held at this temperature for 1 h before cooling to 200 °C. Upon reaching this temperature the now protonic zeolite was exposed to 0.25% NH3 in N2 (40 mL min−1) for 4 h, followed by flushing in inert for an additional 4 h. Finally, the sample was heated in inert (66 mL min−1) to 650 °C (10 °C min−1) to release any adsorbed NH3. Quantification was achieved with calibrant gas.
![[thin space (1/6-em)]](https://www.rsc.org/images/entities/char_2009.gif) 000 to 60
000 to 60![[thin space (1/6-em)]](https://www.rsc.org/images/entities/char_2009.gif) 000 cm3 g−1 h−1.
000 cm3 g−1 h−1.
        ![[thin space (1/6-em)]](https://www.rsc.org/images/entities/char_2009.gif) 000 cm3 g−1 h−1.
000 cm3 g−1 h−1.
        | Footnote | 
| † Electronic supplementary information (ESI) available: Notes on preliminary synthesis studies, crystallization behavior and morphology, X-ray diffraction refinement, N2 isotherms, breakthrough curves and acid site characterization data, in addition to catalytic testing data. See DOI: https://doi.org/10.1039/d3ta03444e | 
| This journal is © The Royal Society of Chemistry 2023 |